Most common failures | No# failures |
---|
Headlamp aim out of alignment | 152 |
Parking brake: efficiency below requirements |3.7.B.7| | 100 |
Registration plate lamp issues | 90 |
Service brake: efficiency below requirements |3.7.B.7| | 89 |
Brake pipe excessively corroded | 60 |
Windscreen wiper does not clear the windscreen effectively | 44 |
Rear parking brake recording little or no effort | 30 |
Registration plate issues | 30 |
Brakes imbalanced across an axle | 29 |
Offside Rear fog lamp not working |1.3.2b| | 26 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 26 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 24 |
Rear brake binding | 23 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 19 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 17 |
Nearside Stop lamp not working |1.2.1b| | 17 |
Offside Stop lamp not working |1.2.1b| | 17 |
Offside Rear Rear fog lamp not working |1.3.2b| | 16 |
Rear brake application uneven | 15 |
Horn not working |1.6.2a| | 15 |
Nearside Side repeater not working |1.4.A.2c| | 14 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 13 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 12 |
Emissions not tested |7.0| | 12 |
Offside Front position lamp|s| not working |1.1.A.3b| | 12 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 12 |
Offside rear brake recording little or no effort |3.7.B.5a| | 12 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 11 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 11 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 10 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 10 |
Parking brake lever has no reserve travel |3.1.6b| | 10 |
Windscreen has damage | 10 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 10 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 9 |
Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 9 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 9 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 9 |
Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 8 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 8 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 8 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 8 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 8 |
Indicator tell tale inoperative |1.4.A.2a| | 8 |
Brake load sensing valve linkage seized |3.6.E.3| | 8 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 8 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 8 |
Exhaust system not adequately supported |7.1.1| | 8 |
Centre Statutory seat belt missing |5.1.1| | 7 |
Offside Side repeater not working |1.4.A.2c| | 7 |
Rear Exhaust system not adequately supported |7.1.1| | 7 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 7 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 7 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 6 |
Rear Exhaust has a part missing |7.1.1a| | 6 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 6 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 6 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 6 |
Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 6 |
Offside Rear Stop lamp not working |1.2.1b| | 6 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 6 |
Nearside Side repeater incomplete |1.5.A1b| | 6 |
Offside Rear fog lamp missing |1.3.2a| | 6 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 6 |
Offside Indicator tell tale inoperative |1.4.A.2a| | 5 |
Front brake disc in such a condition that it is seriously weakened | 5 |
Exhaust has a part missing |7.1.1a| | 5 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 5 |
Rear Mechanical brake component has restricted free movement | 5 |
Offside Front brake disc excessively pitted |3.5.1h| | 5 |
Nearside Front Side repeater incomplete |1.5.A1b| | 5 |
Steering system excessively tight |2.2.D.1| | 5 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 5 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 5 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 5 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 5 |
Rear fog lamp tell tale not working |1.3.1b| | 5 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 5 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 4 |
Nearside Statutory seat belt missing |5.1.1| | 4 |
Offside Side repeater incomplete |1.5.A1b| | 4 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 4 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 4 |
Offside front brake binding |3.7.B.1| | 4 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 4 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Fuel tank leaking |7.2.3| | 4 |
Offside Obligatory mirror insecure |8.1.1| | 4 |
Stop lamp not working |1.2.1b| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 4 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
Nearside Rear Stop lamp not working |1.2.1b| | 4 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 4 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 4 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
Fuel system component leaking |7.2.3| | 4 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 4 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 4 |
Drag link end ball joint has excessive play |2.2.B.1f| | 4 |
Nearside Front brake disc excessively pitted |3.5.1h| | 4 |
Nearside Front Direction indicator incomplete |1.5.A1b| | 4 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 4 |
Brake hose excessively deteriorated | 4 |
Nearside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 3 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 3 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 3 |
Rear Exhaust mounting missing |7.1.1b| | 3 |
Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 3 |
Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 3 |
Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 3 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 3 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 3 |
Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Centre Exhaust system not adequately supported |7.1.1| | 3 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 3 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 3 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
Offside Rear Rear fog lamp insecure |1.3.2a| | 3 |
Offside Rear Brake load sensing valve linkage seized |3.6.E.3| | 3 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 3 |
Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 3 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 3 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 3 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 3 |
Driver`s seat insecure |6.2.A.1| | 3 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
Indicator switch faulty |1.4.A.1| | 3 |
Front Exhaust system not adequately supported |7.1.1| | 3 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 3 |
Front Body has a sharp edge caused by damage |6.1.C.1| | 3 |
Offside Rear Direction indicator not working |1.4.A.2c| | 3 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 3 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Front Side repeater missing |1.4.A.2b| | 3 |
Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Rear Braking system leaking |3.6.A.1| | 3 |
Offside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside rear brake grabbing severely |3.7.A.5b| | 2 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 2 |
Offside Front Side repeater incomplete |1.5.A1b| | 2 |
Offside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 2 |
Nearside Rear Direction indicator incomplete |1.5.A1b| | 2 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
Centre Exhaust mounting missing |7.1.1b| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Rear Braking system leaking |3.6.A.1| | 2 |
Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 2 |
Nearside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
Nearside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 2 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Nearside Rear Leaf spring cracked |2.4.B.1a| | 2 |
Offside Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
Direction indicators not working |1.4.A.2c| | 2 |
Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 2 |
Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 2 |
Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
Nearside front brake juddering severely |3.7.A.2b| | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 2 |
Front passenger seat insecure |6.2.3| | 2 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 2 |
Offside Front Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Mechanical brake component has restricted free movement | 2 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 2 |
Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 2 |
Front Fuel system component leaking |7.2.3| | 2 |
Offside Headlamp aim beam image too far to the right |1.6.B4| | 2 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 2 |
Offside Front brake disc excessively scored |3.5.1h| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 2 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
Nearside Ball joint ball pin shank loose |2.2.B.1c| | 2 |
Nearside Rear Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
Offside Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Offside front brake juddering severely |3.7.A.2b| | 2 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 2 |
Nearside Front Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
Nearside Obligatory mirror insecure |8.1.1| | 2 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
Windscreen wiper blade insecure | 2 |
Nearside Front passenger seat insecure |6.2.3| | 2 |
Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 2 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 2 |
Offside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 2 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Rear Rear position lamp|s| incomplete |1.1.4a| | 2 |
Nearside Front Direction indicators not working |1.4.A.2c| | 2 |
Rear Rear fog lamp missing |1.3.2a| | 2 |
Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Centre Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
Offside Front Side repeater incorrect colour |1.4.A.2f| | 2 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Rear Rear fog lamp insecure |1.3.2a| | 2 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
Offside Side repeater incorrect colour |1.4.A.2f| | 2 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
Nearside Front Front passenger seat insecure |6.2.3| | 2 |
Parking brake: efficiency below requirements |3.7.D.4| | 2 |
Nearside Passenger`s seat insecure |6.2.A.1| | 2 |