Most common failures | No# failures |
---|
Headlamp aim out of alignment | 17 |
Service brake: efficiency below requirements |3.7.B.7| | 17 |
Brake pipe excessively corroded | 17 |
Horn not working |1.6.2a| | 11 |
Brakes imbalanced across an axle | 9 |
Windscreen wiper does not clear the windscreen effectively | 9 |
Offside Rear fog lamp not working |1.3.2b| | 9 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 5 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 5 |
Brake hose excessively deteriorated | 5 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 4 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 3 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Registration plate lamp issues | 3 |
Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
Rear Mechanical brake component has restricted free movement | 3 |
Rear parking brake recording little or no effort | 3 |
Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
Offside Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Offside Rear reflector missing |1.5.1a| | 2 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Registration plate issues | 2 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
Indicator tell tale inoperative |1.4.A.2a| | 2 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Parking brake: efficiency below requirements |3.7.B.7| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Rear brake application uneven | 2 |
Nearside Side repeater not working |1.4.A.2c| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Rear brake binding | 2 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |1.1.21 |e| |i|| | 2 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 2 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill quarter panel |5.3.6 |a| |i|| | 2 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength front mount inner sill out rigger |5.3.6 |a| |i|| | 2 |
Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Front Brake hose leaking |3.6.A.1| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Nearside Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Power steering malfunctioning |2.3.3a| | 1 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Nearside Front Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Leaf spring splayed and action impaired |2.4.B.1c| | 1 |
Offside Front Leaf spring splayed and action impaired |2.4.B.1c| | 1 |
Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Offside Front Rear fog lamp tell tale not working |1.3.1b| | 1 |
Nearside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Offside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Nearside Front Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
Offside Front Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Nearside Rear Upper Shock absorber insecure |2.7.2b| | 1 |
Nearside Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch section marked |5.3.6 |a| |i|| | 1 |
Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch section marked |5.3.6 |a| |i|| | 1 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Rear Brake performance not tested |3.7.A.1| | 1 |
Brake hose damaged | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Offside Side repeater incomplete |1.5.A1b| | 1 |
Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Rear reflector missing |1.5.1a| | 1 |
Offside Rear fog lamp missing |1.3.2a| | 1 |
Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Power steering component|s| leaking |2.3.3b| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded lower bulkhead |under bonnet| |3.6.C.3| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Emissions not tested |7.0| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Rear Leaf spring fractured |2.4.B.1a| | 1 |
Nearside Rear Suspension spring mounting prescribed area is fractured |2.4.A.3| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Statutory seat belt missing |5.1.1| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Front Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Front Parking brake mechanism/associated mounting prescribed area is inadequately repaired |3.1.9| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Offside Front Steering system fouling |2.2.D.2a| | 1 |
Offside Front An item not tested |Manual| | 1 |
Nearside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Front Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear fog lamp insecure |1.3.2a| | 1 |
Centre Front Statutory seat belt missing |5.1.1| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Front passenger seat insecure |6.2.3| | 1 |
Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Emissions not tested |7.4.B.1| | 1 |
Nearside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded front |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded rear |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded front |2.4.A.3| | 1 |
Offside Front Front suspension locking device ineffective bottom shock bolt |2.5.A.4| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded step |5.2.6| | 1 |
Nearside Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
Offside Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Rear Inner Suspension spring mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded chasis |2.4.A.3| | 1 |
Nearside Rear Inner Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded front floor |2.4.A.3| | 1 |
Nearside Rear Inner Suspension spring mounting prescribed area is inadequately repaired front fixing |2.4.A.3| | 1 |
Electrical wiring insecure under dash |1.9.2a| | 1 |
Offside Front Inner Steering component mounting prescribed area is excessively corroded wheel arch |2.2.C.1h| | 1 |
Nearside Rear Lower Shock absorbers insecurely attached bolt not nylock |5.3.2 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner quarter panel |5.3.6 |a| |i|| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis |6.1.B.2| | 1 |
Nearside Rear Electrical wiring damaged, likely to cause a short trailer socket |1.9.2b| | 1 |
Offside Rear Electrical wiring damaged and bare wires exposed fog light |1.9.2c| | 1 |
Trailer electrical socket damaged so that lead cannot be securely connected |1.9.3b| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis |6.1.B.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis |6.1.B.2| | 1 |
Offside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Nearside Rear Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Nearside Rear Leaf spring to axle securing nut insecure U clamps |2.4.B.7b| | 1 |
Headlamp switch faulty dip/main beam switch |1.7.1| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor/step |6.1.B.2| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor/step |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings seat base |6.1.B.2| | 1 |
Windscreen wiper blade insecure | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Centre Exhaust system not adequately supported split |7.1.1| | 1 |
Rear Exhaust system not adequately supported insecure |7.1.1| | 1 |
Brake load sensing valve seized |3.6.E.3| | 1 |
Rear Brake hose inappropriately repaired insecure |3.6.A.3| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill/jack point |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill/jack point |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis under steering box |6.1.B.2| | 1 |
Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting under arch x2 |6.2.2 |d| |i|| | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting under arch x4 |6.2.2 |d| |i|| | 1 |
Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced x2 |6.1.1 |c| |i|| | 1 |
Offside Front Vehicle structure strengthening plate or fastening insecure chassis insufficent weld |6.1.1 |b| |i|| | 1 |
Offside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded chassis section |2.4.A.3| | 1 |