| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 22 |
| Parking brake: efficiency below requirements |3.7.B.7| | 17 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 14 |
| Brake pipe excessively corroded | 14 |
| Registration plate issues | 12 |
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 7 |
| Rear parking brake recording little or no effort | 7 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Brake hose excessively deteriorated | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Offside Front coil spring fractured |2.4.C.1a| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Side repeater not working |1.4.A.2c| | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 2 |
| Nearside Outer Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Front coil spring cracked |2.4.C.1a| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Registration plate lamp issues | 2 |
| Bonnet cannot be secured in the closed position |8.4.1| | 2 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Exhaust has a major leak of exhaust gases rear silencer (6.1.2 (a)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wheel arch (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wheel arch (6.2.2 (d) (i)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Chassis onto floor (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Chassis inner wing area (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Chassis liner wing area (6.2.2 (d) (i)) | 1 |
| Offside Rear Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Brake pipe inadequately clipped main to rear |3.6.B.1| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded anti roll bar bracket mounting |2.4.A.3| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength floorpan |5.3.6 |a| |i|| | 1 |
| Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength rear floorpan |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis at anti roll bar mounting |5.3.6 |a| |i|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
| Nearside Front Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
| Offside Front Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction wiper not parking (3.1 (a) (ii)) | 1 |
| Nearside Front Outer Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Outer Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front suspension has serious deterioration of the bonding between metal and flexible material of an upper support bearing |2.5.B.3a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Anti-lock braking system warning lamp does not illuminate (1.6 (a)) | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn inner bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn inner bush (5.3.4 (a) (i)) | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle centre door has no outer handle (6.2.3 (a)) | 1 |
| Offside Front passenger door cannot be opened from outside the vehicle centre door has no outer handle (6.2.3 (a)) | 1 |
| Nearside Seat belt not functioning as intended centre row of seats do not have seat belts (7.1.2 (c)) | 1 |
| Offside Seat belt not functioning as intended centre seats do not have seat belts fitted (7.1.2 (c)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear bush has play (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn upper arm bushes have play (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn upper arm bushes have play (5.3.4 (a) (i)) | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn n/s/r upper arm has play in inner bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn o/s/r upper arm has play in bushes (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn o/s/r lower front arm has play in bushes (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn front of hub (5.3.4 (a) (i)) | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn front of hub (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Centre Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Outer Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced rear subframe mounting point |6.1.1 |c| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill jacking point |5.3.6 |a| |i|| | 1 |
| Exhaust system insecure front bracket insecure |6.1.2 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front coil spring cracked |2.4.C.1a| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Brake cable locking device missing |3.5.1l| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Rear reflector not red in colour |1.5.1d| | 1 |
| Offside Front Rear reflector not red in colour |1.5.1d| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Front suspension has excessive movement at wishbone bearing |2.5.A.1c| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Lower Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Nearside Rear Upper Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Offside Rear Upper Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Nearside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
| Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Outer Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Fluid suspension pipe leaking |2.4.D.2| | 1 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Centre Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Obligatory mirror missing |8.1.1| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |