| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Brake pipe excessively corroded | 12 |
| Headlamp aim out of alignment | 7 |
| Brake hose excessively deteriorated | 6 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Registration plate lamp issues | 4 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 4 |
| Rear brake binding | 3 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside front brake binding |3.7.B.1| | 3 |
| Rear Exhaust mounting missing |7.1.1b| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Registration plate issues | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Exhaust emits dense blue smoke at idle (8.2.1.2 (f)) | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Centre Rear Statutory seat belt missing |5.1.1| | 2 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Brakes imbalanced across an axle | 2 |
| Stop lamp remains on when the brakes are released | 2 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Inner Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering both side |6.1.1 |c| |ii|| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Nearside Rear Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Nearside Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Centre Rear Fluid suspension pipe leaking |2.4.D.2| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Offside Track rod end loose |2.2.B.1d| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Windscreen has damage | 1 |
| Nearside Front coil spring cracked |2.4.C.1a| | 1 |
| Brake pipe leaking |3.6.A.1| | 1 |
| Radius arm corroded and seriously weakened |2.4.G.1| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Front Prop shaft flexible coupling excessively deteriorated (6.1.7 (d) (i)) | 1 |
| Rear Prop shaft flexible coupling excessively deteriorated (6.1.7 (d) (i)) | 1 |
| Front Prop shaft flexible coupling excessively deteriorated |6.1.7 |d| |i|| | 1 |
| Rear Prop shaft flexible coupling excessively deteriorated |6.1.7 |d| |i|| | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Windscreen washer not working | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Statutory seat belt missing |5.1.1| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Centre Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Centre Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Inner Front Upper Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Fluid suspension pipe leaking |2.4.D.2| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Position lamp switch does not illuminate the front and rear position lamps with a single operation |1.1.A.2| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened |2.4.G.1| | 1 |
| Offside Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Front Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |