| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 23 |
| Registration plate lamp issues | 9 |
| Rear brake binding | 8 |
| Brakes imbalanced across an axle | 7 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Windscreen washer not working | 3 |
| Brake pipe excessively corroded | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Horn not working |1.6.2a| | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Front Steering damper leaking oil |2.2.C.1f| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Axle beam has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Fuel cap/sealing device sealing washer torn |7.2.4c| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Nearside Front Inner Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength cross member |5.3.6 |a| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength cross member |5.3.6 |a| |i|| | 1 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Registration plate issues | 1 |
| Indicator switch faulty stalk not staying in position |1.4.A.1| | 1 |
| Offside Front Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Nearside Front Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Steering column universal joint has excessive play idle control arm |2.1.5| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded front wheel arm area |2.4.A.3| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Lower Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Power steering pump insecure |2.3.6| | 1 |
| Nearside Front Electrical wiring inadequately supported |1.9.2a| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Lower Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Lower Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Outer Front Steering locking device missing |2.2.C.1g| | 1 |
| Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Centre Obligatory mirror missing |8.1.1| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Steering wheel locking device insecure |2.1.6| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Headlamp aim beam image obviously incorrect nearside and offside |1.8.A.1b| | 1 |
| Suspension component mounting prescribed area is inadequately repaired neartside and offside front crossmember to chassis |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is inadequately repaired nearside and offside rear floor |2.4.A.3| | 1 |
| Suspension component mounting prescribed area is excessively corroded nearside and offside rear floor to arch |2.4.A.3| | 1 |
| Nearside Rear Braking system leaking onto disc |3.6.A.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Offside Front Inner Steering locking device insecure onto track rod |2.2.C.1g| | 1 |
| Nearside Seat belt buckle not functioning as intended will not pull out |7.1.2 |d|| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Main beam tell-tale not working operates on dipped beam |4.9.1 |a| |ii|| | 1 |
| Nearside Steering linkage ball joint has excessive play Tie rod end on idler arm |2.1.3 |b| |i|| | 1 |
| Offside Steering linkage ball joint has excessive play tie rod end on steering drop arm |2.1.3 |b| |i|| | 1 |
| Offside Seat belt anchorage loose should be washered to prevent pull through |7.1.1 |b|| | 1 |
| Nearside Seat belt likely to become detached in the event of a collision should be washered to prevent pull through |7.1.1 |a| |ii|| | 1 |
| Offside Rear Brake disc contaminated |1.1.14 |b|| | 1 |
| Nearside Rear Brake disc contaminated |1.1.14 |b|| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Centre Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front brake caliper locking device missing |3.5.1l| | 1 |
| Offside Front brake caliper locking device missing |3.5.1l| | 1 |
| Nearside Rear Upper Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Sub-frame attachment rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Front Inner Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
| Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Front Upper Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Rear Lower Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases box |7.1.2| | 1 |
| Rear position lamp|s| not working both |1.1.A.3b| | 1 |
| Offside Rear Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings small holl |6.1.B.2| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis |6.1.B.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear brake application uneven | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen has damage | 1 |