Most common failures | No# failures |
---|
Headlamp aim out of alignment | 12 |
Registration plate lamp issues | 10 |
Parking brake: efficiency below requirements |3.7.B.7| | 6 |
Windscreen wiper does not clear the windscreen effectively | 5 |
Rear brake binding | 5 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Brake hose damaged | 3 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Fuel cap/sealing device sealing washer torn |7.2.4c| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Rear Fuel pipe leaking |7.2.3| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Brake pipe excessively corroded | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Power steering malfunctioning |2.3.3a| | 2 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 2 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Rear parking brake recording little or no effort | 2 |
All position lamps not working |1.1.A.3b| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Front Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Rear Braking system leaking |3.6.A.1| | 1 |
Rear brake application uneven | 1 |
Offside rear brake grabbing severely |3.7.A.5b| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Nearside Rear Mechanical brake component locking device insecure |3.5.1l| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
Nearside Front Brake hose leaking on a hydraulic braking system |1.1.12 |c| |ii|| | 1 |
Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Nearside Front Upper Axle swivel pins and bushes swivel pin and/or bush excessively worn |5.1.2 |b| |i|| | 1 |
Nearside Front Lower Axle swivel pins and bushes swivel pin and/or bush excessively worn |5.1.2 |b| |i|| | 1 |
Offside Front Upper Axle swivel pins and bushes swivel pin and/or bush excessively worn |5.1.2 |b| |i|| | 1 |
Offside Front Lower Axle swivel pins and bushes swivel pin and/or bush excessively worn |5.1.2 |b| |i|| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Fuel pipe leaking |7.2.3| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wheel arch area |6.1.B.2| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Fuel hose leaking |7.2.3| | 1 |
Nearside Front Statutory seat belt missing |5.1.1| | 1 |
Offside Front Statutory seat belt missing |5.1.1| | 1 |
Horn sounds harsh or grating |1.6.2e| | 1 |
Power steering pump leaking from a failed seal |2.3.3b| | 1 |
Offside Front Upper Steering pivot point has excessive play King pin |2.2.B.1g| | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Electrical wiring insecure battery negative terminal |1.9.2a| | 1 |
Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded crossmember corroded within 30cm of antiroll bar mounting |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded crossmember corroded within 30cm of antiroll bar mounting |2.4.A.3| | 1 |
Drag link end ball joint has excessive play ball joints worn n/s and o/s of arm |2.2.B.1f| | 1 |
Rear Exhaust has a major leak of exhaust gases section of exhaust |back box| |7.1.2| | 1 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Lower Steering column universal joint has excessive play |2.1.5| | 1 |
Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Rear Exhaust has a major leak of exhaust gases silencer |7.1.2| | 1 |
Lower Steering column flexible coupling has excessive play |2.1.5| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Direction indicator not working |1.4.A.2c| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Steering box insecure |2.2.B.1a| | 1 |
Nearside Rear Direction indicator incorrect colour red |1.4.A.2f| | 1 |
Offside Rear Direction indicator incorrect colour red |1.4.A.2f| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush top suspension joint |2.4.G.2| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Centre Rear Exhaust mounting missing |7.1.1b| | 1 |
Centre Fuel pipe leaking |7.2.3| | 1 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
An item not tested |Manual| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
rear parking |secondary| brakes imbalanced | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Brakes imbalanced across an axle | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Battery insecure |1.9.1| | 1 |
Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Steering component mounting prescribed area is fractured |2.2.C.1h| | 1 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Windscreen washer not working | 1 |