| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 43 |
| Headlamp aim out of alignment | 40 |
| Registration plate lamp issues | 19 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Offside Rear fog lamp not working |1.3.2b| | 14 |
| Parking brake: efficiency below requirements |3.7.B.7| | 13 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 10 |
| Brake hose excessively deteriorated | 8 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
| Rear parking brake recording little or no effort | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 6 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 5 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 5 |
| Registration plate issues | 5 |
| Emissions not tested |7.0| | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Offside Front coil spring fractured |2.4.C.1a| | 4 |
| Rear Exhaust system not adequately supported |7.1.1| | 4 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 4 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Brake pedal has no servo assistance |3.3.B.2| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Front coil spring incomplete |2.4.C.1a| | 2 |
| Rear Fuel system component leaking |7.2.3| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 2 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Centre Rear Statutory seat belt missing |5.1.1| | 2 |
| Offside Front coil spring cracked |2.4.C.1a| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Side repeater insecure |1.4.A.2b| | 2 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Rear Fluid suspension unit leaking |2.4.D.2| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Inner Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Rear Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Inner Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Centre Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Outer Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Steering system excessively rough ball joints siezed (2.1.1 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill end (5.3.6 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases Middle section (6.1.2 (a)) | 1 |
| Parking brake lever inoperative Parking brake records no effort on either side. (1.1.6 (d)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Inner wheel arch corroded. Needs welding (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Inner wheel arch corroded. Needs welding (6.2.2 (d) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Offside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Offside Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Nearside Rear Fuel pipe leaking |7.2.3| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Outer Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Upper Shock absorber has an excessively worn shock absorber pivot |2.7.4| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Lower Suspension arm severely distorted |2.4.G.1| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Centre Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing by top strut mount |5.3.6 |a| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing by spring mount |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing by strut mount |5.3.6 |a| |i|| | 1 |
| Bonnet cannot be secured in the closed position |3.1 |b| |i|| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Outer Rear Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake hose damaged | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Brake load sensing valve inoperative |3.6.E.3| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Rear Fluid suspension accumulator leaking |2.4.D.2| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength flitch panel |5.3.6 |a| |i|| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength flitch panel |5.3.6 |a| |i|| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front Direction indicator missing |1.4.A.2b| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Offside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced |2.4.F.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| An item not tested |Manual| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Nearside Rear An item not tested |Manual| | 1 |
| Windscreen wiper blade insecure | 1 |
| Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Outer Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Centre Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Emissions not tested bad running (8.2.1.2 (d)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Horn not working |1.6.2a| | 1 |
| Rear brake application uneven | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded hole in sill within 30cm of suspension mounting |2.4.A.3| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |