| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Registration plate lamp issues | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Rear parking brake recording little or no effort | 6 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Brake pipe excessively corroded | 5 |
| Brakes imbalanced across an axle | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
| Horn not working |1.6.2a| | 3 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Windscreen wiper blade insecure | 3 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Braking system leaking |3.6.A.1| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Centre Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Trailer electrical socket insecure |1.9.3a| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
| Front Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Nearside Rear Brake load sensing valve has been disconnected and was fitted as standard |3.6.E.2| | 1 |
| Nearside Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Nearside Outer Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Inner Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear brake application uneven | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Central Brake pipe at imminent risk of failure or fracture Leaking (1.1.11 (a)) | 1 |
| Brake performance unable to be tested Due to leak (1.2.1 (g)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Rear Brake drum contaminated (1.1.14 (b)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Body has a projection caused by corrosion |6.1.C.1| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |