| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 17 |
| Headlamp aim out of alignment | 9 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Brake hose excessively deteriorated | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Brake pipe excessively corroded | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Rear brake binding | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Emissions not tested |7.0| | 2 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 2 |
| Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Nearside Rear passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |6.1.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |6.1.2| | 1 |
| Front Leaf spring fractured |2.4.B.1a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Brake hydraulic reservoir fluid level significantly below minimum level (1.1.10 (d) (ii)) | 1 |
| Rear Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Centre Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake pedal anti-slip provision worn smooth (1.1.2 (c)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front Horn not working (7.7 (a)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Rear Wheel stud|s| loose |4.2.A.1e| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Windscreen has damage | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Emissions not tested |7.4.B.1| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength brake back plate (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength brake back plate (5.3.6 (a) (i)) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Side repeater insecure |1.4.A.2b| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Offside Front Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Registration plate issues | 1 |
| Towbar assembly inappropriately modified |6.6.7| | 1 |
| Emissions not tested Due to major leak of exhaust |7.3.A.1| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Service brake application uneven across the axle |3.7.D.2b| | 1 |