Most common failures | No# failures |
---|
Registration plate lamp issues | 1025 |
Headlamp aim out of alignment | 996 |
Brake pipe excessively corroded | 816 |
Parking brake: efficiency below requirements |3.7.B.7| | 504 |
Windscreen wiper does not clear the windscreen effectively | 489 |
Rear parking brake recording little or no effort | 301 |
Offside Rear fog lamp not working |1.3.2b| | 265 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 193 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 189 |
Brakes imbalanced across an axle | 186 |
Registration plate issues | 183 |
Service brake: efficiency below requirements |3.7.B.7| | 164 |
Offside Stop lamp not working |1.2.1b| | 159 |
Brake load sensing valve linkage seized |3.6.E.3| | 159 |
Nearside Stop lamp not working |1.2.1b| | 156 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 144 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 144 |
Horn not working |1.6.2a| | 137 |
Windscreen has damage | 133 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 132 |
Parking brake lever has no reserve travel |3.1.6b| | 132 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 123 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 114 |
Rear brake binding | 112 |
Offside Front position lamp|s| not working |1.1.A.3b| | 110 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 109 |
Front brake disc in such a condition that it is seriously weakened | 108 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 100 |
Exhaust has a major leak of exhaust gases |7.1.2| | 88 |
Offside Headlamp not working on dipped beam |1.7.5a| | 86 |
Offside Rear Stop lamp not working |1.2.1b| | 84 |
Offside Front brake disc excessively pitted |3.5.1h| | 83 |
Offside Rear Rear fog lamp not working |1.3.2b| | 80 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 79 |
Nearside Headlamp not working on main beam |1.7.5a| | 78 |
Nearside Rear Stop lamp not working |1.2.1b| | 78 |
Nearside Side repeater not working |1.4.A.2c| | 76 |
Emissions not tested |7.0| | 73 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 71 |
Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 70 |
Brake hose excessively deteriorated | 70 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 69 |
Nearside Front brake disc excessively pitted |3.5.1h| | 67 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 66 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 65 |
Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 63 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 62 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 61 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 60 |
Offside Headlamp not working on main beam |1.7.5a| | 60 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 60 |
Offside Side repeater not working |1.4.A.2c| | 59 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 57 |
Rear Exhaust has a part missing |7.1.1a| | 56 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 55 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 55 |
Offside rear brake recording little or no effort |3.7.B.5a| | 54 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 54 |
Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 54 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 54 |
Rear brake application uneven | 54 |
Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 54 |
Fuel system component leaking |7.2.3| | 53 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 52 |
Offside Steering rack gaiter split |2.2.D.2d| | 52 |
Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 51 |
Rear Exhaust system not adequately supported |7.1.1| | 51 |
Nearside Steering rack gaiter split |2.2.D.2d| | 51 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 50 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 50 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 49 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 48 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 48 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 47 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 47 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 46 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 45 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 44 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 43 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 43 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 43 |
Rear Rear fog lamp not working |1.3.2b| | 43 |
Exhaust system not adequately supported |7.1.1| | 42 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 42 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 42 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 41 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 41 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 40 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 40 |
Front brake application uneven | 40 |
Nearside Front Side repeater not working |1.4.A.2c| | 40 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 39 |
Offside Rear brake disc excessively pitted |3.5.1h| | 39 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 38 |
Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 36 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 36 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 36 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 35 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 35 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 35 |
Offside Front Direction indicators incorrect colour |1.4.A.2f| | 33 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 33 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 33 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 31 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 31 |
Rear fog lamp not working |1.3.2b| | 31 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 30 |
Offside Front Headlamp not working on main beam |1.7.5a| | 30 |
Nearside Rear brake disc excessively pitted |3.5.1h| | 30 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 29 |
Rear brake disc in such a condition that it is seriously weakened | 28 |
Rear fog lamp tell tale not working |1.3.1b| | 28 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 28 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 27 |
Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 27 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 27 |
Rear Exhaust mounting missing |7.1.1b| | 26 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 26 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 26 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 26 |
Nearside Front Direction indicator incomplete |1.5.A1b| | 25 |
Windscreen wiper blade insecure | 24 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 24 |
Steering system excessively tight |2.2.D.1| | 24 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 24 |
Rear Stop lamp not working |1.2.1b| | 24 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 24 |
Centre Exhaust system not adequately supported |7.1.1| | 23 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 23 |
Offside Front Side repeater not working |1.4.A.2c| | 23 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 23 |
Hazard warning switch faulty |1.4.B.1d| | 23 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 23 |
Fuel pipe leaking |7.2.3| | 23 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 22 |
Offside Front brake disc excessively scored |3.5.1h| | 22 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 22 |
Seat belt locking mechanism does not secure or release |5.2.5a| | 22 |
Fuel tank leaking |7.2.3| | 21 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 21 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 21 |
Indicator tell tale inoperative |1.4.A.2a| | 21 |
Front Exhaust system not adequately supported |7.1.1| | 21 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 21 |
Battery insecure |1.9.1| | 21 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 21 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 21 |
Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 21 |
Offside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 20 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 20 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 20 |
Exhaust has a part missing |7.1.1a| | 20 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 20 |
Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 19 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 19 |
Stop lamp not working |1.2.1b| | 19 |
Offside Rear fog lamp insecure |1.3.2a| | 19 |
Nearside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 19 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 19 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 19 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 19 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 19 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 19 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 19 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 19 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 19 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 19 |
Brake load sensing valve seized |3.6.E.3| | 19 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 18 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 18 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 18 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 18 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 17 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 17 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 17 |
Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 17 |
Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 17 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 17 |
Driver`s seat insecure |6.2.A.1| | 17 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 17 |
Front Direction indicator incorrect colour |1.4.A.2f| | 16 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 16 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 16 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 16 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 16 |
Offside Front Direction indicator incomplete |1.5.A1b| | 16 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 16 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 16 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 16 |
Nearside Front Direction indicator not working |1.4.A.2c| | 16 |
Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 16 |
Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 16 |
Brake cable has wires broken and is significantly weakened |3.5.1b| | 15 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 15 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 15 |
Front brake disc excessively pitted |3.5.1h| | 15 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 15 |
Offside Front Direction indicator not working |1.4.A.2c| | 15 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 15 |
Nearside Front brake disc excessively scored |3.5.1h| | 15 |
Centre Seat belt retracting mechanism defective |5.2.5b| | 15 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 14 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 14 |
Indicator switch faulty |1.4.A.1| | 14 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 14 |
Direction indicators not working |1.4.A.2c| | 14 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 14 |
Rear brake disc excessively pitted |3.5.1h| | 14 |
Nearside Side repeater incomplete |1.5.A1b| | 14 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 14 |
Fuel hose leaking |7.2.3| | 14 |
Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 14 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 14 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 13 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 13 |
Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 13 |
Nearside Headlamp aim not tested |1.8.A.1c| | 13 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 13 |
Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 13 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 12 |
Offside Obligatory mirror insecure |8.1.1| | 12 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 12 |
Brake pedal spongy |3.3.B.1b| | 12 |
Nearside Front Windscreen wiper blade missing |8.2.2| | 12 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 12 |
Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 12 |
Front position lamp|s| not working |1.1.A.3b| | 12 |
Nearside Rear Brake load sensing valve linkage seized |3.6.E.3| | 12 |
Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 12 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 11 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 11 |
Nearside Front Side repeater incomplete |1.5.A1b| | 11 |
Offside front brake juddering severely |3.7.A.2b| | 11 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 11 |
Offside Rear Rear position lamp|s| incomplete |1.1.4a| | 11 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 11 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 11 |
Offside Rear Direction indicator incomplete |1.5.A1b| | 11 |
Nearside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 11 |
Offside Rear Direction indicator not working |1.4.A.2c| | 11 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 11 |
Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 11 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 11 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 11 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 10 |
Nearside Front Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 10 |
Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 10 |
Centre Front Statutory seat belt missing |5.1.1| | 10 |
Nearside Front Side repeater missing |1.4.A.2b| | 10 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 10 |
Nearside Rear position lamp|s| incomplete |1.1.4a| | 10 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 10 |
Offside Indicator tell tale inoperative |1.4.A.2a| | 10 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 10 |
Rear Mechanical brake component has restricted free movement | 10 |
Brake performance not tested |3.7.A.1| | 10 |
Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 10 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 10 |