| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 18 |
| Headlamp aim out of alignment | 13 |
| Registration plate issues | 8 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 6 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 5 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 4 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Brake pipe excessively corroded | 4 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Windscreen has damage | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front coil spring broken |2.4.C.1a| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front coil spring fractured |2.4.C.1a| | 2 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Outer Obligatory mirror does not provide a view to the rear |3.3 |c|| | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt Rear arm |5.3.4 |b| |ii|| | 1 |
| Nearside Front Suspension arm ball joint excessively worn Rear arm |5.3.4 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front coil spring cracked |2.4.C.1a| | 1 |
| Offside Rear coil spring cracked |2.4.C.1a| | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Parking brake lever insecure |3.1.3b| | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Radius arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement rear arm |2.4.G.2| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt front arm |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Nearside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Nearside Rear Integral body structure strengthening plate or fastening so insecure that structural rigidity is seriously reduced (6.1.1 (b) (ii)) | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Headlamp not working on main beam both front (4.1.1 (a) (ii)) | 1 |
| Coil spring fractured or broken both front (5.3.1 (b) (i)) | 1 |
| Headlamp aim beam image obviously incorrect both |1.8.A.1b| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
| Bonnet cannot be secured in the closed position |3.1 |b| |i|| | 1 |
| Bonnet primary retaining device ineffective |3.1 |c|| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |