| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Brake pipe excessively corroded | 6 |
| Headlamp aim out of alignment | 6 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Brakes imbalanced across an axle | 4 |
| Registration plate issues | 4 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Nearside Front coil spring broken |2.4.C.1a| | 2 |
| Registration plate lamp issues | 2 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Upper Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Offside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn ball joint (5.3.4 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced floor (7.1.1 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Front Lower coil spring incomplete |2.4.C.1a| | 1 |
| Offside Front Lower coil spring incomplete |2.4.C.1a| | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Inner sill to floor |7.1.1 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Inner sill to floor |7.1.1 |a| |i|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn Link rod bush |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn Link rod bush |5.3.4 |a| |i|| | 1 |
| Nearside Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded Inner to floor |5.2.6| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Rear Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Windscreen has damage | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Rear brake binding | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Inner Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Emissions not tested |7.0| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion wing |6.1.C.1| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction at time of test lamp off (8.2.1.2 (h)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Stop lamp|s| all not working o/s and n/s rear brake hoses perished |4.3.1 |a| |iii|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Upper Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |