| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 39 |
| Headlamp aim out of alignment | 34 |
| Registration plate lamp issues | 20 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 18 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 13 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 12 |
| Parking brake: efficiency below requirements |3.7.B.7| | 12 |
| Offside Stop lamp not working |1.2.1b| | 11 |
| Offside Rear fog lamp not working |1.3.2b| | 9 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Nearside Stop lamp not working |1.2.1b| | 8 |
| Offside Front coil spring fractured |2.4.C.1a| | 6 |
| Brake hose excessively deteriorated | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Emissions not tested |7.0| | 6 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 6 |
| Rear parking brake recording little or no effort | 6 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 5 |
| Registration plate issues | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 3 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Nearside Indicator tell tale inoperative |1.4.A.2a| | 2 |
| An item not tested |Manual| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Rear brake binding | 2 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Offside Front Anti-lock braking system wiring excessively damaged (1.6 (d)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Centre Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Steering box deformed and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Steering system excessively tight |2.2.D.1| | 1 |
| Offside Outer Track rod end excessively corroded and unserviceable |2.2.C.1d| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Direction indicator incomplete |1.5.A1b| | 1 |
| Nearside front brake grabbing severely |3.7.A.2b| | 1 |
| Offside rear brake grabbing severely |3.7.A.5b| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Anti-roll bar linkage insecure d/ bushes |2.4.G.1| | 1 |
| Offside Rear Brake pipe leaking to load valve |3.6.A.1| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Anti-lock braking system warning lamp sequence is incorrect |3.4.1d| | 1 |
| Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Lower Suspension arm attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Brake pipe leaking |3.6.A.1| | 1 |
| Exhaust engine idle speed too high |7.3.D.1| | 1 |
| Rear Brake valve leaking |3.6.A.1| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Fuel pipe union leaking |7.2.3| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Rear Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Offside Rear Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Offside Front coil spring incomplete |2.4.C.1a| | 1 |
| Rear Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Nearside Front Intermediate drop arm deformed and unserviceable |2.2.C.1d| | 1 |
| Centre Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Front Windscreen wiper control missing |8.2.1a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Rear Torsion bar fractured |2.4.E.1a| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Front Seat belt insecurely fixed to the seat |5.2.1a| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear brake application uneven | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Coil spring not correctly located |2.4.C.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
| Nearside Front Valve stem seriously misaligned |4.1.D.1e| | 1 |
| Offside Obligatory mirror not clearly visible from the drivers seat or incapable of being adjusted to be clearly visible from the driver`s seat |8.1.1d| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Offside Rear Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Inner Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Inner Rear Fuel pipe leaking |7.2.3| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Nearside Rear Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Front Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Rear Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Steering locking device insecure |2.2.C.1g| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Brake pedal fouling on other parts of the vehicle |3.3.A.4| | 1 |