| Most common failures | No# failures |
|---|
| Brake hose excessively deteriorated | 334 |
| Registration plate lamp issues | 298 |
| Headlamp aim out of alignment | 193 |
| Windscreen wiper does not clear the windscreen effectively | 163 |
| Brake pipe excessively corroded | 152 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 85 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 82 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 63 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 63 |
| Registration plate issues | 62 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 55 |
| Front brake disc in such a condition that it is seriously weakened | 45 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 44 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 40 |
| Nearside Headlamp not working on main beam |1.7.5a| | 38 |
| Rear Exhaust system not adequately supported |7.1.1| | 37 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 36 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 36 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 32 |
| Anti-lock braking system warning lamp indicates an ABS fault | 31 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 28 |
| Battery insecure |1.9.1| | 28 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 27 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 26 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 24 |
| Nearside Stop lamp not working |1.2.1b| | 23 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 22 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 22 |
| Exhaust system not adequately supported |7.1.1| | 21 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 21 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 19 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 18 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 17 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 17 |
| Emissions not tested |7.0| | 17 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 17 |
| Parking brake lever has no reserve travel |3.1.6b| | 17 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 16 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 16 |
| Nearside Rear Stop lamp not working |1.2.1b| | 15 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 15 |
| Brake hose damaged | 14 |
| Parking brake: efficiency below requirements |3.7.B.7| | 14 |
| Front Exhaust system not adequately supported |7.1.1| | 14 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 13 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 13 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 12 |
| Rear parking brake recording little or no effort | 11 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 11 |
| Centre Exhaust system not adequately supported |7.1.1| | 11 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 11 |
| Brakes imbalanced across an axle | 11 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 10 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 10 |
| Offside Rear Brake hose excessively damaged |3.6.B.4d| | 10 |
| Rear fog lamp not working |1.3.2b| | 10 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 10 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 10 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 10 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 9 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 9 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 9 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 9 |
| Service brake: efficiency below requirements |3.7.C.1a| | 9 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 9 |
| Windscreen has damage | 8 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 8 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 8 |
| Offside Headlamp not working on main beam |1.7.5a| | 8 |
| Fuel system component leaking |7.2.3| | 8 |
| Offside Stop lamp not working |1.2.1b| | 8 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 7 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 7 |
| Nearside Front Brake hose excessively damaged |3.6.B.4d| | 7 |
| Trailer electrical socket insecure |1.9.3a| | 7 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 7 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 7 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 7 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 6 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 6 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 6 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 6 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 6 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 6 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 6 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 6 |
| Offside Rear Stop lamp not working |1.2.1b| | 6 |
| Brake performance not tested |3.7.A.1| | 6 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 5 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 5 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 5 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 5 |
| Nearside Front Anti-lock braking system component excessively damaged |3.4.2| | 5 |
| Offside Rear coil spring broken |2.4.C.1a| | 5 |
| Nearside Rear Brake hose excessively damaged |3.6.B.4d| | 5 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 5 |
| Offside Front brake disc excessively pitted |3.5.1h| | 5 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 5 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 5 |
| Front brake disc excessively pitted |3.5.1h| | 5 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 5 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 5 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 5 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 4 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Front coil spring broken |2.4.C.1a| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Offside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 4 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Offside Front Anti-lock braking system component excessively damaged |3.4.2| | 4 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Bonnet cannot be secured in the closed position |8.4.1| | 4 |
| Hazard warning lamps inoperative |1.4.B.1b| | 4 |
| Nearside Front coil spring fractured |2.4.C.1a| | 4 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 4 |
| Offside Front All position lamps not working |1.1.A.3b| | 4 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 4 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 4 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 4 |
| Hazard warning switch faulty |1.4.B.1d| | 4 |
| Offside Ball joint has excessive play |2.2.B.1f| | 4 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 4 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 4 |
| Nearside Front coil spring broken |2.4.C.1a| | 4 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 4 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 4 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 4 |
| Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 4 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Rear brake binding | 4 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 4 |