| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 23 |
| Headlamp aim out of alignment | 21 |
| Brake pipe excessively corroded | 18 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 16 |
| Rear fog lamp tell tale not working |1.3.1b| | 14 |
| Offside Rear fog lamp not working |1.3.2b| | 11 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Registration plate issues | 10 |
| Registration plate lamp issues | 10 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 10 |
| Nearside Headlamp not working on main beam |1.7.5a| | 6 |
| Offside Headlamp not working on main beam |1.7.5a| | 6 |
| Rear brake binding | 6 |
| Horn not working |1.6.2a| | 6 |
| Brake hose excessively deteriorated | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Rear parking brake recording little or no effort | 5 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Driver`s seat insecure |6.2.A.1| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 3 |
| Brakes imbalanced across an axle | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Offside front brake juddering severely |3.7.A.2b| | 2 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Windscreen wiper blade insecure | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Offside Front brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Outer Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Nearside Front Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Rear Statutory seat belt missing |5.1.1| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Front position lamp|s| missing |1.1.A.3a| | 1 |
| Offside Front position lamp|s| missing |1.1.A.3a| | 1 |
| Nearside Front Direction indicator missing |1.4.A.2b| | 1 |
| Offside Front Direction indicator missing |1.4.A.2b| | 1 |
| Rear Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Rear Body has a projection caused by damage |6.1.C.1| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Offside Rear Brake hose bulging under pressure (1.1.12 (d)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected (5.3.6 (a) (ii)) | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor pan (7.1.1 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced floor pan (7.1.1 (a) (i)) | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside front brake grabbing severely |3.7.A.2b| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Rear Suspension component mounting prescribed area is severely distorted |2.4.A.3| | 1 |
| Offside Rear Seat belt anchorage prescribed area is severely distorted |5.2.6| | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floorpan (5.3.6 (a) (i)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Body panel insecure wing insecure at bottom (6.2.1 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill area (5.3.6 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength lower arm mount area (inside wheel arch) (5.3.6 (a) (i)) | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Inner Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition (8.1.1 (a)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Brake hose has insufficient room to move | 1 |
| Brake servo vacuum pipe deteriorated |3.6.C.1b| | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Nearside Front Lower Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting floor has hole (6.2.2 (d) (i)) | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp not working (1.3.2b) | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Rear Rear fog lamp excessively damaged so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Rear brake disc excessively scored |3.5.1h| | 1 |
| Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust emits visible black smoke at idle |7.3.A.2b| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Rear Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front brake caliper securing device loose |3.5.1j| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Front brake application uneven | 1 |
| Nearside Front Front suspension has a loose unit in the upper support bearing assembly |2.5.B.3b| | 1 |
| Offside Front Front suspension has a loose unit in the upper support bearing assembly |2.5.B.3b| | 1 |
| Front position lamp|s| not working both |1.1.A.3b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Rear Tie bar/rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Suspension spring mounting prescribed area is excessively corroded floor |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Nearside Rear Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Centre Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Lower Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Lower Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Brake servo damaged and function impaired |3.6.A.2c| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |