Most common failures | No# failures |
---|
Headlamp aim out of alignment | 31 |
Parking brake: efficiency below requirements |3.7.B.7| | 15 |
Registration plate lamp issues | 15 |
Registration plate issues | 10 |
Offside Rear fog lamp not working |1.3.2b| | 9 |
Rear parking brake recording little or no effort | 7 |
Rear brake binding | 7 |
Rear fog lamp not working |1.3.2b| | 6 |
Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 4 |
Rear fog lamp tell tale not working |1.3.1b| | 4 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 4 |
Centre Stop lamp not working |1.2.1b| | 4 |
Brakes imbalanced across an axle | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Windscreen wiper does not clear the windscreen effectively | 4 |
Rear fog lamp switch missing |1.3.1a| | 3 |
Offside Front Steering rack gaiter split |2.2.D.2d| | 3 |
Brake pipe excessively corroded | 3 |
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
Rear fog lamp tell tale missing |1.3.1b| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
Rear fog lamp missing |1.3.2a| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Nearside Steering rack gaiter split |2.2.D.2d| | 2 |
Nearside Rear coil spring fractured |2.4.C.1a| | 2 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Rear fog lamp insecure |1.3.2a| | 2 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Brake hose damaged | 2 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Rear fog lamp emits a light other than red |1.3.2e| | 2 |
Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Offside Front coil spring broken |2.4.C.1a| | 2 |
All position lamps not working |1.1.A.3b| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Horn not working |1.6.2a| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 2 |
Horn control missing |1.6.1| | 2 |
Rear brake disc in such a condition that it is seriously weakened | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Rear Rear fog lamp missing |1.3.2a| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Rear Exhaust has a part missing |7.1.1a| | 1 |
Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear coil spring fractured |2.4.C.1a| | 1 |
Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Rear Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Offside Rear fog lamp insecure |1.3.2a| | 1 |
Rear brake application uneven | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Offside Rear fog lamp missing |1.3.2a| | 1 |
Nearside Outer Seat belt anchorage prescribed area is excessively corroded sill corroded and holed within 30cms of roll cage mount which has seatbelt attached |5.2.6| | 1 |
Nearside Inner Seat belt anchorage prescribed area is excessively corroded sill/floor pan corroded and holed within 30cms of roll cage mount which has seatbelt attached |5.2.6| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
Nearside Front Macpherson strut worn and seriously weakened |2.4.G.2| | 1 |
Headlamp missing both |4.1.1 |a| |ii|| | 1 |
Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
Subframe mounting prescribed area excessively damaged significantly reducing structural strength boot floor missing |5.3.6 |a| |i|| | 1 |
Offside Seat belt anchorage prescribed area strength or continuity significantly reduced floor |7.1.1 |a| |i|| | 1 |
Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill repair inadequate |7.1.1 |a| |i|| | 1 |
Central Front Brake hose excessively damaged |1.1.12 |b| |ii|| | 1 |
Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
Rear fog lamp switch missing (4.5.3 (a) (ii)) | 1 |
Offside Rear Brake inadequately mounted touching wheel (1.1.21 (c)) | 1 |
Body component damaged and likely to cause injury rear off body has sharps edges likely to cause injury (6.2.1 (a) (i)) | 1 |
Nearside Front Suspension arm modified so the suspension is likely to foul other components touching anti roll bar (5.3.3 (c) (ii)) | 1 |
Offside Front Suspension arm modified so the suspension is likely to foul other components touching anti roll bar (5.3.3 (c) (ii)) | 1 |
Battery insecure |1.9.1| | 1 |
Offside Front Lower Front suspension locking device missing |2.5.A.4| | 1 |
Offside Rear Brake hose twisted |3.6.B.4c| | 1 |
Offside Front Brake hose kinked |3.6.B.4b| | 1 |
Nearside Front Upper Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Upper Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Lower Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Lower Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Rear brake caliper leaking |3.6.A.1| | 1 |
Offside Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Rear fog lamp does not face the rear |1.3.2a| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Nearside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement D BUSH |2.4.G.2| | 1 |
Offside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings arch |6.1.B.2| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Brake pedal anti-slip provision loose |1.1.2 |c|| | 1 |
Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
Power steering pump insecure adjustment bracket loose |2.1.5 |d| |i|| | 1 |
Anti-roll bar linkage pin or bush excessively worn nearside and offside rear "d" bushes |5.3.4 |a| |i|| | 1 |
Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength marked with yellow chalk |5.3.6 |a| |i|| | 1 |
Mechanical brake component has restricted free movement | 1 |
Nearside Rear brake disc contaminated by grease |3.5.1h| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded inner arch |5.2.6| | 1 |
Rear Rear fog lamp insecure |1.3.2a| | 1 |
brake disc excessively pitted |3.5.1h| | 1 |
Offside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength inner sill |2.4.A.3| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Coil spring fractured or broken Both rear |5.3.1 |b| |i|| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Central Stop lamp not working |1.2.1b| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Exhaust has a major leak of exhaust gases centre joint |7.1.2| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Outer Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Central Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Offside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Rear fog lamp does not emit a steady red light |4.5.4 |a|| | 1 |
Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i)) | 1 |
Nearside Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded wheel arch |5.2.6| | 1 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Upper Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Exhaust has a major leak of exhaust gases rear section |7.1.2| | 1 |
Centre Rear fog lamp not working |1.3.2b| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Offside Stop lamp not working |1.2.1b| | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Offside Rear coil spring broken |2.4.C.1a| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Offside Rear Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill to inner sill has equate repair, panel not welded?? |6.1.1 |c| |i|| | 1 |
Nearside Headlamp light source and lamp not compatible no image |4.1.4 |c|| | 1 |
Offside Headlamp light source and lamp not compatible No image |4.1.4 |c|| | 1 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users MAIN BEAM STUCK ON |1.8.A.1a| | 1 |
Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Windscreen has damage | 1 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Nearside Front Body insecure and dangerous to other road users wing |6.1.B.1b| | 1 |
Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
Nearside Front Coil spring mounting loose |2.4.C.3a| | 1 |
Nearside Front Lower Steering locking device missing Ball joint |2.2.C.1g| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |