| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 52 |
| Headlamp aim out of alignment | 51 |
| Parking brake: efficiency below requirements |3.7.B.7| | 36 |
| Parking brake lever has no reserve travel |3.1.6b| | 31 |
| Registration plate issues | 26 |
| Windscreen wiper does not clear the windscreen effectively | 23 |
| Rear parking brake recording little or no effort | 15 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 10 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
| Registration plate lamp issues | 8 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Offside Steering rack gaiter split |2.2.D.2d| | 7 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 7 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 5 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 5 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 5 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 4 |
| Front brake excessively fluctuating | 4 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 4 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 4 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 3 |
| Windscreen washer not working | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Windscreen has damage | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Brakes imbalanced across an axle | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Emissions not tested |7.0| | 2 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Windscreen wiper blade missing |8.2.2| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Offside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Offside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 2 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Rear brake disc excessively pitted |3.5.1h| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear brake application uneven | 2 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Ball joint ball pin shank loose o/s/front ball joint loose |2.2.B.1c| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Inner Ball joint has excessive play |2.2.B.1f| | 1 |
| Inner Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Steering column has excessive movement up and down (2.2.2 (a)) | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Brake hose has insufficient room to move | 1 |
| Offside Front Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Nearside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Outer Tie bar/rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear brake binding | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn front |5.3.4 |a| |i|| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced hole in a floor |7.1.1 |a| |i|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Front Upper Suspension arm pin or bush excessively worn front bush |5.3.4 |a| |i|| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced floor |7.1.1 |a| |i|| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside Brake pipe leaking centre floor |3.6.A.1| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Offside Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Rear brake disc excessively scored |3.5.1h| | 1 |
| Headlamps matched pair are incorrectly positioned |1.7.3| | 1 |
| Nearside Front brake disc excessively pitted (3.5.1h) | 1 |
| Offside Front brake disc excessively pitted (3.5.1h) | 1 |
| Nearside Rear brake disc excessively pitted (3.5.1h) | 1 |
| Offside Rear brake disc excessively pitted (3.5.1h) | 1 |
| Parking brake lever has no reserve travel (3.1.6b) | 1 |
| Offside Front Headlamp not working on dipped beam (1.7.5a) | 1 |
| Body component likely to become detached Roof lining insecure, high risk of distraction and risk of falling off. (6.2.1 (a) (ii)) | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Front Windscreen wiper not working Both (3.4 (a)) | 1 |
| Nearside Front Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Rear Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Offside Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Nearside Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Dipswitch does not operate immediately when selected on dipped beam |4.1.3 |b|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Offside Rear Upper Anti-roll bar linkage attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 1 |
| Offside Rear Outer Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt boot split. (2.1.3 (g) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt boot split. (2.1.3 (g) (ii)) | 1 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt boot split. (2.1.3 (g) (ii)) | 1 |
| Offside Front Electrical wiring inadequately supported |1.9.2a| | 1 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Exhaust emissions likely to be affected by an induction leak |8.2.1.1 |b|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Fuel cap/sealing device missing fuel cap. |6.1.3 |b| |i|| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Front Brake disc significantly and obviously worn inboard side surface. (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn inboard side surface. (1.1.14 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Parking brake inoperative on one side Both sides (1.4.1 (a)) | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Stop lamp not working all lamps |1.2.1b| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Upper Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Central Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Fuel system component insecure |7.2.1| | 1 |
| Offside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Front Fluid suspension unit leaking BOTH. |2.4.D.2| | 1 |
| Exhaust system not adequately supported Fouling rear sub-frame. |7.1.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Outer Rear Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Tie bar/rod rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases pipe detached (6.1.2 (a)) | 1 |
| Nearside Rear Lower Suspension rod pin or bush excessively worn tie bar bush (5.3.4 (a) (i)) | 1 |
| Boot lid cannot be secured in the closed position (6.2.1 (e)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting missing (5.3.3 (a) (ii)) | 1 |
| Nearside Rear Lower Suspension rod ball joint excessively worn rear tie bar (5.3.4 (a) (i)) | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Outer Rear Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Outer Rear Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Outer Rear Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Outer Rear Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Speedometer cannot be illuminated (7.8 (c) (ii)) | 1 |
| Front brake application uneven | 1 |
| Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Brake pipe leaking on a hydraulic braking system Front to rear (1.1.11 (b) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |