| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 115 |
| Registration plate issues | 26 |
| Windscreen wiper does not clear the windscreen effectively | 18 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Registration plate lamp issues | 6 |
| Nearside Side repeater not working |1.4.A.2c| | 5 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 5 |
| Rear brake binding | 5 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 4 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 3 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 3 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
| Windscreen washer not working | 3 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 3 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 2 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
| Nearside Side repeater excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 2 |
| Bootlid cannot be secured in the closed position |6.4.1| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Nearside Headlamp insecure |1.7.3| | 2 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 2 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 2 |
| Nearside Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 2 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Offside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Centre Front Upper Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Side repeater has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn Anti roll bar Link |5.3.4 |a| |i|| | 1 |
| Nearside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Front Body component insecure Wheel arch liner/mudflap |6.2.1 |a| |i|| | 1 |
| Offside Front Body component insecure Wheelarch liner /mudflat insecure |6.2.1 |a| |i|| | 1 |
| Offside Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Driver`s airbag missing |5.4.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Direction indicator not working side |1.4.A.2c| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative Both front |4.1.6 |a| |ii|| | 1 |
| Central Stop lamp not working |1.2.1b| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Front Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.3 |a|| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Service brake excessively binding handbrake sticking on |1.2.1 |f|| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Headlamp aim beam image obviously incorrect both |1.8.A.1b| | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Stop lamp not working both side |1.2.1b| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Power steering component|s| leaking |2.3.3b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Nearside Outer Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush d-bush |2.4.G.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Headlamp cleaning device inoperative |1.7.2| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front Horn not working |1.6.2a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Steering column top bearing excessively worn (2.2.2 (b)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Rear Service brake excessively binding Both (1.2.1 (f)) | 1 |
| Service brake excessively binding Both rear brakes, suspect rear inner parking brake shoes (1.2.1 (f)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Headlamp lens seriously defective No beam pattern visible (4.1.1 (b) (ii)) | 1 |
| Nearside Rear Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Side repeater not working OFFSIDE INOPERATIVE (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect LHD headlamp appears to be fitted (4.1.2 (c)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Rear Inner Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Emissions not tested Engine misfire present (8.2.1.2 (d)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Rear Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect kick up to the right (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect kick up to the right (4.1.2 (c)) | 1 |
| Nearside Front Seat belt installation causes a lap belt to be incorrectly positioned across the occupant (10.1 (u)) | 1 |
| Offside Front Seat belt installation causes a lap belt to be incorrectly positioned across the occupant (10.1 (u)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Headlamp aim projected beam image is obviously incorrect Both. (4.1.2 (c)) | 1 |
| Nearside Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| Nearside Direction indicator not working side flasher (4.4.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Direction indicator with a multiple light source more than 1/2 not functioning (4.4.1 (a) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Brake cable damaged (1.1.15 (a)) | 1 |
| Nearside Rear Brake cable damaged (1.1.15 (a)) | 1 |
| Exhaust has a major leak of exhaust gases Suspect at front lower pipe area at front V section (6.1.2 (a)) | 1 |
| Brake lever has restricted free movement Parking brake lever tight in operation, suspect cables causing issue (1.1.15 (e)) | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Brake pipe likely to become detached or damaged Brake pipe bracket has become detached from the body work (1.1.11 (d) (ii)) | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Rear Upper Suspension arm fractured (5.3.3 (b) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Front Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Steering column top bearing excessively worn Excessive play in top steering column bearing (2.2.2 (b)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Rear Brake disc significantly and obviously worn both on inner edges (1.1.14 (a) (i)) | 1 |
| Nearside Front Side repeater light intensity significantly reduced ns wing repeater, (4.4.3 (a)) | 1 |
| Stop lamp(s) not working high level (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |