| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 24 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 21 |
| Brake pipe excessively corroded | 19 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Registration plate lamp issues | 11 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 10 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 8 |
| Offside Steering rack gaiter split |2.2.D.2d| | 8 |
| Horn not working |1.6.2a| | 7 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Offside Side repeater not working |1.4.A.2c| | 6 |
| Rear brake binding | 5 |
| Brakes imbalanced across an axle | 5 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
| Offside front brake binding |3.7.B.1| | 5 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 5 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 5 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 4 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Windscreen washer not working | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Nearside Rear Seat belt attachment fitting badly deteriorated |5.2.3| | 2 |
| Rear brake disc excessively pitted |3.5.1h| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Seat belt attachment fitting badly deteriorated |5.2.3| | 2 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Nearside Track rod end loose |2.2.B.1d| | 2 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Rear front brake binding |3.7.B.1| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Seat belt adjustment fitting badly deteriorated |5.2.3| | 1 |
| Offside Outer Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Brake hose leaking |3.6.A.1| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Offside Rear front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Offside Front Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Nearside Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Direction indicators have less than 50% of the light sources illuminating all lamps dull |1.4.A.2c| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Rear Braking system leaking bleeder leaking |3.6.A.1| | 1 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Steering rack fractured and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Road wheel distorted |4.2.A.1a| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Track rod end loose |2.2.B.1d| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Brake master cylinder defective but brake still operating |1.1.10 |b| |i|| | 1 |
| Steering rack has excessive free play detected at the steering wheel |steering rack fitted| steering lower uj |2.3 |a| |i|| | 1 |
| Nearside Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Centre Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Steering arm has relative movement at its fixings rack end |2.2.B.1h| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Nearside Obligatory mirror insecure |8.1.1| | 1 |
| Windscreen wiper control is inaccessible to the driver |8.2.1a| | 1 |
| Nearside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Rear Seat belt installation attached to floor without reinforcement plates or with plates of an unsuitable size/contour |10.1 |m|| | 1 |
| Offside Rear Seat belt installation attached to floor without reinforcement plates or with plates of an unsuitable size/contour |10.1 |m|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Power steering malfunctioning |2.3.3a| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Front brake application uneven | 1 |
| Front front brake binding |3.7.B.1| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp Indicator |1.1.A.3f| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Offside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Driver`s seat with a defective structure |6.2.5 |a| |i|| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Registration plate issues | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Offside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front Brake pipe leaking on a hydraulic braking system Across subframe to nearside (1.1.11 (b) (ii)) | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Fluid leak harmful to the environment or a risk to other road users Engine coolant leak from engine area, water pump area (8.4.1 (a) (i)) | 1 |
| Nearside Steering rack gaiter split (2.2.D.2d) | 1 |
| Offside Steering rack gaiter split (2.2.D.2d) | 1 |
| Offside Front Direction indicators not working (1.4.A.2c) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Central Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| All position lamps adversely affected by the operation of another lamp When indicators/hazard warning operated (4.2.3 (c)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Rear Exhaust system insecure RUBBER MOUNT (6.1.2 (a)) | 1 |
| Nearside Rear Exhaust system insecure RUBBER MOUNT (6.1.2 (a)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Front Power steering component leaking (2.1.5 (a)) | 1 |