| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 16 |
| Registration plate issues | 10 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Brake pipe excessively corroded | 9 |
| Rear parking brake recording little or no effort | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Nearside Front coil spring fractured |2.4.C.1a| | 7 |
| Headlamp aim out of alignment | 7 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 6 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Registration plate lamp issues | 5 |
| Offside Front coil spring fractured |2.4.C.1a| | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 4 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Battery insecure |1.9.1| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear fog lamp missing |1.3.2a| | 3 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Nearside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front coil spring cracked |2.4.C.1a| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Steering locking device missing |2.2.C.1g| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Emissions not tested |7.0| | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Offside Front coil spring incomplete |2.4.C.1a| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Windscreen washer not working | 2 |
| Rear brake binding | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint required greasing |2.5.B.1a| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Lower Battery insecure |1.9.1| | 1 |
| Upper Battery insecure |1.9.1| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Air suspension unit deteriorated and likely to fail |2.4.D.1b| | 1 |
| Centre Front Exhaust system not adequately supported |7.1.1| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Side repeater does not face the side (4.4.3 (a)) | 1 |
| Offside Side repeater does not face the side (4.4.3 (a)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis near suspension arm (5.3.6 (a) (i)) | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner & outer sill |6.2.2 |d| |i|| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Exhaust has a major leak of exhaust gases worn through the bottom of stretched pipes |7.1.2| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front coil spring cracked |2.4.C.1a| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Offside Rear Hydraulic brake calliper leaking |1.1.16 |b| |i|| | 1 |
| Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Inner Ball joint has excessive play rack joint |2.2.B.1f| | 1 |
| Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear Brake hose connection leaking on a hydraulic braking system |1.1.12 |c| |ii|| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Offside Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure bolts loose (5.3.3 (a) (i)) | 1 |
| Parking brake lever ratchet not holding correctly (1.1.6 (a)) | 1 |
| Nearside Body panel insecure SILL CORRODED TO EXCESS (6.2.1 (a) (i)) | 1 |
| Offside Body panel insecure SILL CORRODED TO EXCESS (6.2.1 (a) (i)) | 1 |
| Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting SILL (6.2.2 (d) (i)) | 1 |
| Offside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting SILL (6.2.2 (d) (i)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 1 |
| Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Rear fog lamp has a product on the lens so it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Electrical wiring inadequately supported |1.9.2a| | 1 |
| Offside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Seat belt anchorage prescribed area is inadequately repaired floor pan marked in yellow (7.1.1 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Fuel pipe leaking (6.1.3 (b) (i)) | 1 |
| Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Fuel pipe leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Brake hose excessively deteriorated | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Upper Braking system leaking |3.6.A.1| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Lower Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear brake application uneven | 1 |
| Driver`s airbag obviously defective |5.4.1| | 1 |
| Passenger`s airbag obviously defective |5.4.1| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Centre Rear Upper Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Power steering pipe|s| or hose|s| leaking from a seal |2.3.3b| | 1 |
| Offside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Parking brake lever insecure |3.1.3b| | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Brake fluid contaminated (1.8 (a)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Rear Oil leaking excessively from transmission hub oil seal (8.4.1 (a) (i)) | 1 |
| Nearside Side repeater incomplete |1.5.A1b| | 1 |
| Speed limiter plate missing |6.5.A.1a| | 1 |
| Brake cable locking device missing outer cable |3.5.1l| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Main beam `tell-tale` not working |1.7.4c| | 1 |
| Nearside Rear Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Intermediate drop arm likely to become detached (2.1.3 (a) (ii)) | 1 |
| Offside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |