| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 39 |
| Headlamp aim out of alignment | 24 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 19 |
| Registration plate issues | 18 |
| Registration plate lamp issues | 17 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 14 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 13 |
| Brakes imbalanced across an axle | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Rear brake disc in such a condition that it is seriously weakened | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Offside Front Shock absorbers has a serious fluid leak | 5 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 5 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Front Position lamp not working |4.2.1 |a|| | 4 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 4 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 4 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 3 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Nearside Front Shock absorbers has a serious fluid leak | 2 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear Valve stem seriously damaged |5.2.3 |j|| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Rear Headlamp levelling device inoperative ride height sensor linkage |4.1.5 |a|| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Rear Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction |3.1 |a| |ii|| | 1 |
| Nearside Steering retaining device missing |2.2.C.1g| | 1 |
| Offside Steering retaining device missing |2.2.C.1g| | 1 |
| Headlamp levelling device obviously defective |1.7.2| | 1 |
| Nearside Headlamp not working on dipped beam comes on when switched on and goes off will not stay on |1.7.5a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Front Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn D bush |5.3.4 |a| |i|| | 1 |
| Centre Rear Spare wheel carrier insecure |6.4.2| | 1 |
| Centre Rear Spare wheel insecure |6.4.2| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Front brake excessively fluctuating | 1 |
| Rear brake binding | 1 |
| Nearside Rear brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Bonnet cannot be secured in the closed position |3.1 |b| |i|| | 1 |
| Offside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement rear |2.4.G.2| | 1 |
| Windscreen has damage | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Rear Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Position lamp not working both nearside and offside front |4.2.1 |a|| | 1 |
| Nearside Rear Brake slack adjuster seized |1.1.18 |a|| | 1 |
| Headlamp levelling device obviously defective broken |1.7.2| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Front position lamp|s| not working Nearside & Offside |1.1.A.3b| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Central Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement d bush
|2.4.G.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Brake performance not tested BRAKE BINDING |3.7.A.1| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Front Bumper damaged and likely to cause injury when grazed or contacted both sides (6.1.4 (a) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn inner bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn inner bush (5.3.4 (a) (i)) | 1 |
| Front Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Position lamp not working side light bulb inop (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Brake lining(s) less than 1.5 mm thick (1.1.13 (a) (ii)) | 1 |
| Offside Rear Brake lining(s) less than 1.5 mm thick (1.1.13 (a) (ii)) | 1 |
| Offside Service brake excessively binding (1.2.1 (f)) | 1 |
| Steering system excessively rough (2.1.1 (a)) | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp lens defective such that emitted light is adversely affected (4.5.1 (b) (ii)) | 1 |
| Offside Rear Brake lining(s) incorrectly mounted brake locating up going forwards (1.1.13 (c)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn BOTH SIDES (D) BUSH (5.3.4 (a) (i)) | 1 |
| Front Suspension arm pin or bush excessively worn BOTH SIDES (REAR BUSH) (5.3.4 (a) (i)) | 1 |
| Rear Brake cable insecure | 1 |
| Offside Front Position lamp not working side light (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Valve stem seriously damaged split (5.2.3 (j)) | 1 |
| Nearside Rear Hydraulic brake calliper insecurely mounted (1.1.16 (c) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Headlamp levelling device inoperative lever broken (4.1.5 (a)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar likely to fail (5.3.3 (b) (ii)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Boot lid cannot be secured in the closed position Boot not Opening (6.2.1 (e)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point (5.3.6 (a) (i)) | 1 |
| Nearside Front Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Rear Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Offside Rear Outer Suspension component pin or bush excessively worn rear lower upright rose bush (5.3.4 (a) (i)) | 1 |
| Offside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn d bushes both sides (5.3.4 (a) (i)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Steering rack insecure to the extent there is excessive movement at the mountings (2.1.3 (a) (ii)) | 1 |
| Rear Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Headlamp levelling device inoperative broken (4.1.5 (a)) | 1 |
| Offside Rear Exhaust silencer insecure (8.1.1 (b) (i)) | 1 |
| Offside Front Brake disc significantly and obviously worn inner face (1.1.14 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill area (5.3.6 (a) (i)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Front Outer Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding parking brake (1.2.1 (f)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Front Position lamp not working Both sides (4.2.1 (a) (ii)) | 1 |
| Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Front Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Parking brake efficiency below requirements both (1.4.2 (a) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |