| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 46 |
| Headlamp aim out of alignment | 31 |
| Registration plate lamp issues | 18 |
| Registration plate issues | 17 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 14 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 12 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 10 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 9 |
| Rear parking brake recording little or no effort | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Brakes imbalanced across an axle | 7 |
| Rear brake disc in such a condition that it is seriously weakened | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Rear brake binding | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Nearside Front Shock absorbers has a serious fluid leak | 3 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front Shock absorbers has a serious fluid leak | 2 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Rear Rear reflector missing |4.8.2 |a| |ii|| | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front Position lamp not working both |4.2.1 |a|| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Windscreen has damage | 1 |
| Wheel insecure |4.2.A.1c| | 1 |
| Offside Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Headlamp levelling device obviously defective |1.7.2| | 1 |
| Rear Brake disc significantly and obviously worn scored and corroded |1.1.14 |a| |i|| | 1 |
| Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
| Front Macpherson strut has excessive play in the sliding bush or gland |2.5.B.1b| | 1 |
| Emissions not tested electric fault with car only runs on petrel engine can rev engine to test |7.3.A.1| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Offside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Headlamp levelling device obviously defective |1.7.2| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Headlamp not working on dipped beam Off side |1.7.5a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Front Headlamp cleaning device inoperative |1.7.2| | 1 |
| Front brake excessively fluctuating | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Front position lamp|s| not working Both |1.1.A.3b| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Service brake grabbing severely |3.7.C.2| | 1 |
| Service brake juddering severely |3.7.C.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Brake pedal has insufficient reserve travel Parking brake (1.1.2 (a)) | 1 |
| Position lamp not working nearside front (4.2.1 (a) (ii)) | 1 |
| Position lamp not working offside front (4.2.1 (a) (ii)) | 1 |
| Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt nearside front (5.3.4 (b) (ii)) | 1 |
| Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt offside front (5.3.4 (b) (ii)) | 1 |
| Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt offside front inner (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Drivers view of the road through the swept area of the windscreen materially affected by an obstruction (3.1 (a) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment Hits its stop. (1.1.6 (c)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Parking (secondary brake) on a single line braking system grabbing severely (1.3.1 (c)) | 1 |
| Offside Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Offside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Suspension arm pin or bush excessively worn offside front (5.3.4 (a) (i)) | 1 |
| Suspension arm ball joint dust cover no longer prevents the ingress of dirt nearside front (5.3.4 (b) (ii)) | 1 |
| Offside Front Windscreen wiper blade missing (3.4 (b) (ii)) | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Headlamp levelling device inoperative broken (4.1.5 (a)) | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Rear Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Front Position lamp has a product on the lens or light source which shows white light to the rear (4.2.3 (b) (ii)) | 1 |
| Nearside Rear Lower Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Rear Lower Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Front Outer Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Boot leaking grease (6.1.7 (g) (ii)) | 1 |
| Offside Front Position lamp not working Replaced (PRS) (4.2.1 (a) (ii)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment pedal hits floor (1.1.6 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Suspension arm attachment bracket/mounting missing Security nut missing on ball joint (5.3.3 (a) (ii)) | 1 |
| Offside Front Suspension arm attachment bracket/mounting missing Security nut missing on ball joint (5.3.3 (a) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn Severely deteriorated (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn Severely deteriorated (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component pin or bush excessively worn FRONT ROD HUB END IN REAR HUB (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension component pin or bush excessively worn REAR ROD HUB END IN REAR HUB (5.3.4 (a) (i)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn rose bush in hub (5.3.4 (a) (i)) | 1 |
| Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected sill (5.3.6 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |