| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 24 |
| Windscreen wiper does not clear the windscreen effectively | 19 |
| Parking brake: efficiency below requirements |3.7.B.7| | 15 |
| Rear parking brake recording little or no effort | 15 |
| Registration plate issues | 13 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 8 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 5 |
| Registration plate lamp issues | 5 |
| Rear brake binding | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Rear Shock absorbers has a serious fluid leak | 3 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 2 |
| Offside Rear brake caliper leaking |3.6.A.1| | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Windscreen wiper blade insecure | 2 |
| Front brake application uneven | 2 |
| Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear brake disc modified and seriously weakened |3.5.1n| | 2 |
| Offside Rear brake disc modified and seriously weakened |3.5.1n| | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 2 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Horn is a siren |1.6.2c| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Offside front brakes release unevenly |3.7.B.4| | 1 |
| Windscreen has damage | 1 |
| Nearside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Central Front Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Nearside Rear Outer Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Service brake imbalanced across an axle |1.2.1 |b| |i|| | 1 |
| Nearside Rear Hydraulic brake calliper damaged and braking performance affected |1.1.16 |a| |ii|| | 1 |
| Nearside Front Suspension component leaking |5.3.5 |c|| | 1 |
| Spare wheel carrier insecure |6.4.2| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Inner Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Nearside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Offside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested |8.2.1.2 |d|| | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Nearside Rear Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Offside Rear Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Offside Rear Parking brake inoperative on one side not holding on when applied |1.4.1 |a|| | 1 |
| Offside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Nearside Rear Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Nearside Rear Service brake grabbing severely |3.7.C.2| | 1 |
| Electronic stability system warning lamp does not illuminate |3.4.1b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Brakes imbalanced across an axle | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded sill |2.4.A.3| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Nearside Rear Sub-frame corroded and seriously weakened HOLED |5.3.3 |b| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Macpherson strut has excessive movement in the upper support bearing assembly |2.5.B.1b| | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Outer Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brake fluid contaminated (1.8 (a)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Central Rear Anti-roll bar corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Sub-frame corroded and seriously weakened holed (5.3.3 (b) (i)) | 1 |
| Headlamp levelling device inoperative broken (4.1.5 (a)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill under vehicle (5.3.6 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn D bush (5.3.4 (a) (i)) | 1 |
| Offside Front Macpherson strut mounting fractured (5.3.3 (b) (ii)) | 1 |
| Brake disc in such a condition that it is seriously weakened both rear (1.1.14 (a) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Brake disc in such a condition that it is seriously weakened both front (1.1.14 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced wheel arch (7.1.1 (a) (i)) | 1 |
| Offside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced wheel arch (7.1.1 (a) (i)) | 1 |
| Fuel system component defective in the case of LPG/CNG/ LNG or hydrogen systems (6.1.3 (f)) | 1 |
| Nearside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Service brake is causing the steering wheel to severely pull one way sized (1.2.1 (b) (i)) | 1 |
| Emissions not tested lack of engine oil (8.2.1.2 (d)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
| Offside Rear Headlamp levelling device inoperative leveling sensor arm broken (4.1.5 (a)) | 1 |
| Rear Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Seat belt missing center rear seat belt buckle (7.1.2 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Offside Rear Suspension bellows damaged or deteriorated and function is seriously affected (5.3.5 (b) (ii)) | 1 |
| Offside Rear Suspension system inoperative (5.3.5 (a)) | 1 |
| Nearside Front Macpherson strut pin or bush excessively worn top mount (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength under arch (5.3.6 (a) (i)) | 1 |
| Nearside Front Service brake lagging in operation 38% (1.2.1 (d)) | 1 |
| Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |