| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 21 |
| Headlamp aim out of alignment | 20 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Registration plate issues | 8 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 6 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside front brake binding |3.7.B.1| | 4 |
| Registration plate lamp issues | 4 |
| Brake pipe excessively corroded | 4 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Windscreen washer not working | 3 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake hose has insufficient room to move | 1 |
| Offside Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Exhaust has a major leak of exhaust gases centre pipe |6.1.2 |a|| | 1 |
| Nearside Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front brake caliper has restricted free movement |3.5.1k| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Nearside rear brake juddering severely |3.7.A.5b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Anti-roll bar synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Braking system leaking abs pump |3.6.A.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Headlamp levelling device obviously defective |1.7.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced |4.1.4 |b|| | 1 |
| Nearside Front Headlamp aim not tested |4.1.2 |b|| | 1 |
| Offside Front Headlamp aim not tested |4.1.2 |b|| | 1 |
| Nearside Headlamp aim beam image obviously incorrect Polish required |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect Polish required |1.8.A.1b| | 1 |
| Nearside Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Headlamp levelling device inoperative level sensor broken |4.1.5 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Nearside Rear coil spring broken |2.4.C.1a| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Anti-roll bar insecure |2.4.G.1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Front Front suspension has excessive play in a upper suspension ball joint both |2.5.B.1a| | 1 |
| Windscreen has damage | 1 |
| Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Rear Rear fog lamp does not emit a steady red light |4.5.4 |a|| | 1 |
| Front Lower Suspension arm has excessive play in a ball joint BOTH |2.4.G.2| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Emissions not tested Overheated on test |7.3.A.1| | 1 |
| Brake performance not tested Overheated on test |3.7.A.1| | 1 |
| Nearside Front Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Suspension arm pin or bush excessively worn nearside front rear arm bush (5.3.4 (a) (i)) | 1 |
| Suspension arm pin or bush excessively worn offside front rear arm bush (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front Headlamp has a product on the lens so that the light output is severely reduced both (4.1.4 (b)) | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Exhaust has a major leak of exhaust gases middle section (6.1.2 (a)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Valve stem seriously damaged O/S/R (5.2.3 (j)) | 1 |
| Front Headlamp has more than 1/2 LEDs not functioning Bth Side (4.1.1 (a) (ii)) | 1 |
| Offside Front Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Rear Brake cable insecure | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill and wheel arch lower-whole (6.2.2 (d) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Exhaust has a major leak of exhaust gases Located on "Y" pipe (6.1.2 (a)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn Joint play (5.3.4 (a) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (rear) bush (5.3.4 (a) (i)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |