| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 7 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Headlamp aim out of alignment | 6 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Horn not working |1.6.2a| | 4 |
| Brake pipe excessively corroded | 4 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 4 |
| Rear parking brake recording little or no effort | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Front brake application uneven | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 2 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Rear Trailer electrical socket damaged so that lead cannot be securely connected |1.9.3b| | 1 |
| Front Battery insecure |1.9.1| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Brake pipe kinked |3.6.B.2b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Direction indicator lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded STEP UNDERNEATH VEHICLE MARKED YELLOW |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded STEP IN 2 PLACES MARKED YELLOW UNDERNEATH VEHICLE |5.2.6| | 1 |
| Seat belt attachment fitting badly deteriorated |5.2.3| | 1 |
| Windscreen has damage | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Headlamp not in good working order affecting the beam image |1.2.4a| | 1 |
| Rear Emergency exit door cannot be opened from outside the vehicle |6.2.D.1a| | 1 |
| Offside Obligatory mirror seriously damaged affecting the rear view |6.6.1b| | 1 |
| Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| front brake recording little or no effort |3.7.B.5a| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Front Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Lower Steering column universal joint has excessive play |2.1.5| | 1 |
| Offside Front Upper Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Registration plate issues | 1 |
| Nearside Rear Rear position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
| Nearside Rear Rear reflector more than 50% obscured |1.5.1b| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| passenger door does not latch securely closed |6.2.B.1a| | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Front Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| brake disc in such a condition that it is seriously weakened |3.5.1i| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Front passenger seat insecure |6.2.3| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |