| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 19 |
| Fuel system component leaking |7.2.3| | 5 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 4 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 4 |
| Brakes imbalanced across an axle | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Registration plate lamp issues | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 3 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Rear brake application uneven | 2 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
| Steering system excessively tight |2.2.D.1| | 2 |
| Emissions not tested |7.0| | 2 |
| Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Power steering component|s| leaking |2.3.1b| | 1 |
| Fuel tank leaking |6.7.1a| | 1 |
| Steering system excessively rough |2.2.D.1e| | 1 |
| Nearside Rear Seat belt stitching repaired |5.1.B.3c| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Nearside Rear Stop lamp not working |1.3.2a| | 1 |
| Offside Rear Stop lamp not working |1.3.2a| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Exhaust emits clearly visible black smoke during acceleration |7.4.A2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Torque/reaction arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Front Torque/reaction arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Rear rear brakes release unevenly |3.7.B.4| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.4.A2| | 1 |
| Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Brake hose leaking |3.6.A.1| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
| Offside Front Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting wheel arch x3 (6.2.2 (d) (i)) | 1 |
| Offside Front Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting chassis (6.2.2 (d) (i)) | 1 |
| Offside Rear Outer Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting cross member (6.2.2 (d) (i)) | 1 |
| Offside Front Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jaCKING POINT (6.2.2 (d) (i)) | 1 |
| Nearside Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill by sliding door (6.2.2 (d) (i)) | 1 |
| Front Body panel corroded and likely to cause injury wings (6.2.1 (a) (i)) | 1 |
| Offside Front Body panel corroded and likely to cause injury door (6.2.1 (a) (i)) | 1 |
| Nearside Rear Body panel corroded and likely to cause injury sliding door (6.2.1 (a) (i)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front Position lamp not working both side lamps (4.2.1 (a) (ii)) | 1 |
| Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| Offside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Horn not working |1.6.2a| | 1 |
| Battery insecure and likely to fall from carrier both batteries (4.13 (a) (ii)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Windscreen washer not working | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Rear Body panel corroded and likely to cause injury quarter panel (6.2.1 (a) (i)) | 1 |
| Body panel corroded and likely to cause injury both sides rear doors (6.2.1 (a) (i)) | 1 |
| Nearside Rear Body panel corroded and likely to cause injury outer wheel arch (6.2.1 (a) (i)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Indicator switch inoperative (4.4.2 (a) (ii)) | 1 |
| Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Headlamp not working on dipped beam both sides (4.1.1 (a) (ii)) | 1 |
| Headlamp not working on main beam both sides (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Entrance/exit step in such a condition as to affect the stability of passengers during use (9.7 (a) (iii)) | 1 |
| Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength both sides rear panels (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Front Steering component mounting prescribed area is fractured wheel arch (2.1.2 (e) (i)) | 1 |
| Offside Front Lower Steering component mounting prescribed area is fractured inner wing area (2.1.2 (e) (i)) | 1 |
| Offside Front Lower Seat belt anchorage prescribed area strength or continuity significantly reduced floor area holed and filler has been used (7.1.1 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i)) | 1 |
| Fuel tank leaking tank area damp (6.1.3 (b) (i)) | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen |3.5 |a|| | 1 |
| Front Battery insecure and likely to cause a short circuit Both batteries insecure under bonnet. |4.13 |a| |ii|| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Rear Lower Shock absorbers has an excessively worn bush Both rear shock absorber lower bushes worn and perished. |5.3.2 |c|| | 1 |
| Oil leaking excessively from engine Sump and engine saturated in oil. |8.4.1 |a| |i|| | 1 |
| Front Axle swivel pins and bushes swivel pin and/or bush excessively worn Both offside and nearside worn. |5.1.2 |b| |i|| | 1 |
| Front Leaf spring shackle pin or bush excessively worn Both front knocking and excess lateral movement. |5.3.4 |a| |i|| | 1 |
| Central Front Floor excessively deteriorated Holed in central of compartment area, chalk marked. |6.2.4 |a| |i|| | 1 |
| Nearside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Under bonnet, under battery. |6.2.2 |d| |i|| | 1 |
| Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Under bonnet, under battery. |6.2.2 |d| |i|| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Nearside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Rear brake binding | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Offside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Front brake application uneven | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
| Power steering pump leaking from a failed joint |2.3.3b| | 1 |
| Nearside Front Axle king pin is loose in the axle beam |2.5.A.3a| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Outer Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Rear Fuel system component leaking |7.2.3| | 1 |
| Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Intermediate drop arm deformed and unserviceable |2.2.C.1d| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Steering locking device insecure |2.2.C.1g| | 1 |
| Fuel pipe union leaking |7.2.3| | 1 |
| Offside Front Steering component mounting prescribed area is inadequately repaired |2.2.C.1h| | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Rear Rear reflector missing |1.5.1a| | 1 |
| Registration plate issues | 1 |
| Steering column top mounting bracket insecure |2.1.2d| | 1 |
| Offside Front Steering component mounting prescribed area has a deliberate modification which significantly reduces the original strength |2.2.C.1h| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Offside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Outer Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Outer Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Suspension spring mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Offside Drag link end repaired by welding |2.2.C.1e| | 1 |
| Offside Drag link end has had excessive heat applied |2.2.C.1e| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |