Most common failures | No# failures |
---|
Headlamp aim out of alignment | 28 |
Registration plate lamp issues | 23 |
Rear parking brake recording little or no effort | 14 |
Windscreen wiper does not clear the windscreen effectively | 12 |
Brake pipe excessively corroded | 11 |
Rear brake application uneven | 11 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 10 |
Offside Rear fog lamp not working |1.3.2b| | 10 |
Service brake: efficiency below requirements |3.7.B.7| | 9 |
Brakes imbalanced across an axle | 7 |
Parking brake: efficiency below requirements |3.7.B.7| | 7 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 6 |
Horn not working |1.6.2a| | 5 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 5 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 5 |
Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 4 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
Registration plate issues | 4 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 4 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Power steering component|s| leaking |2.3.3b| | 3 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Bonnet cannot be secured in the closed position |8.4.1| | 3 |
Rear fog lamp switch faulty |1.3.1a| | 3 |
Rear fog lamp tell tale not working |1.3.1b| | 3 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Offside Headlamp insecure |1.7.3| | 3 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 3 |
Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 2 |
Emissions not tested |7.0| | 2 |
Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Nearside Headlamp insecure |1.7.3| | 2 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Rear brake binding | 2 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 2 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
Nearside rear brake grabbing severely |3.7.A.5b| | 2 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Battery insecure |1.9.1| | 2 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Centre Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Service brake: efficiency below requirements |3.7.D.4| | 1 |
Offside Side repeater insecure |1.4.A.2b| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Nearside Front Brake hose leaking |3.6.A.1| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Exhaust has a major leak of exhaust gases |6.3.2a| | 1 |
Rear Exhaust has part of the system excessively deteriorated |6.3.1a| | 1 |
Nearside rear brake grabbing severely |3.8.A.5b| | 1 |
Nearside Headlamp not in good working order affecting the beam image |1.2.4a| | 1 |
Driver`s seat security significantly reduced |6.5.14| | 1 |
Nearside Front Passenger`s seat security significantly reduced |6.5.14| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Shock absorber has a serious fluid leak |2.7.3| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Headlamp aim not tested |1.8.A.1c| | 1 |
Centre Front Statutory seat belt missing |5.1.1| | 1 |
Front Steering damper leaking oil |2.2.C.1f| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Rear Anti-roll bar worn and seriously weakened |2.4.G.1| | 1 |
Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
Front Fuel system component leaking |7.2.3| | 1 |
Windscreen has damage | 1 |
Nearside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Offside Front Direction indicators not working |1.4.A.2c| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Steering system excessively tight |2.2.D.1e| | 1 |
Offside Front Axle king pin has excessive play in pin and/or bush, adversely affecting the steering |2.5.A.3a| | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
rear brake juddering severely |3.7.A.5b| | 1 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Rear All position lamps not working |1.1.A.3b| | 1 |
Offside Front position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Rear Fuel system component leaking |7.2.3| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear Air suspension has no suspension movement |2.4.D.5| | 1 |
Offside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Bonnet retaining device ineffective |8.4.2| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Front Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Front Steering component damaged and unserviceable |2.2.C.1d| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Nearside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
Rear Exhaust mounting missing |7.1.1b| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
Nearside rear brake juddering severely |3.7.A.5b| | 1 |
Offside rear brake juddering severely |3.7.A.5b| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Offside Front Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Central Statutory seat belt missing buckle |5.1.1| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front brake disc insecure |3.5.1i| | 1 |
Offside Front brake disc modified and seriously weakened |3.5.1n| | 1 |
Exhaust has a major leak of exhaust gases back section |7.1.2| | 1 |
Front brake excessively fluctuating | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Nearside Outer Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Fuel tank insecure straps broken |7.2.1| | 1 |
Offside rear brake grabbing severely |3.7.A.5b| | 1 |
Centre Front Steering component deformed and unserviceable |2.2.C.1d| | 1 |
Centre Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
Offside Front front brake juddering severely |3.7.A.2b| | 1 |
Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Centre Steering damper leaking oil |2.2.C.1f| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
Front Brake pivot has restricted free movement |3.5.1k| | 1 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Offside Front Steering component damaged and unserviceable |2.2.C.1d| | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Fuel tank insecure ( Gas Tank Bracket broken ) (6.1.3 (a) (i)) | 1 |
Nearside Front Brake disc significantly and obviously worn Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Offside Front Brake disc significantly and obviously worn Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Nearside Front Anti-roll bar pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Cab Floor Close To Offside Front Shock Absorber Top Mounting |5.3.6 |a| |i|| | 1 |
Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Battery Tray Holed By Corrosion |6.1.1 |c| |i|| | 1 |
Offside Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Rear rear brake grabbing severely |3.7.A.5b| | 1 |
Nearside Front Lower Shock absorber insecure |2.7.2b| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Brake cable locking device insecure |3.5.1l| | 1 |