Most common failures | No# failures |
---|
Registration plate lamp issues | 40 |
Headlamp aim out of alignment | 28 |
Service brake: efficiency below requirements |3.7.B.7| | 18 |
Windscreen wiper does not clear the windscreen effectively | 15 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 14 |
Brakes imbalanced across an axle | 13 |
Brake pipe excessively corroded | 8 |
Offside Rear fog lamp not working |1.3.2b| | 7 |
Rear brake application uneven | 7 |
Horn not working |1.6.2a| | 7 |
Parking brake: efficiency below requirements |3.7.B.7| | 6 |
Registration plate issues | 5 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 5 |
Nearside Stop lamp not working |1.2.1b| | 5 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
Centre Exhaust mounting missing |7.1.1b| | 4 |
Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 3 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 3 |
All direction indicators not working (4.4.1 (a) (ii)) | 3 |
Exhaust system not adequately supported |7.1.1| | 3 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Rear parking brake recording little or no effort | 2 |
Fuel pipe leaking |7.2.3| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
Nearside Front Headlamp reflector seriously defective (4.1.1 (b) (ii)) | 2 |
Offside Side repeater not working |1.4.A.2c| | 2 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Windscreen washer not working | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Rear Suspension system inoperative (5.3.5 (a)) | 2 |
Emissions not tested (8.2.1.2 (d)) | 2 |
Horn not working |7.7 |a| |ii|| | 2 |
Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Bonnet retaining device ineffective |8.4.2| | 2 |
Rear Stop lamp not working |1.2.1b| | 2 |
Horn not working (7.7 (a) (ii)) | 2 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Axle king pin is loose in the axle beam |2.5.A.3a| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Offside Rear Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Windscreen has damage | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Nearside Front Brake hose leaking |3.6.A.1| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Headlamp not in good working order affecting the beam image |1.2.4a| | 1 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded which significantly reduces the original strength |2.4.A.2| | 1 |
Centre Front Seat belt locking mechanism does not secure or release |5.1.B.6a| | 1 |
Exhaust emissions carbon monoxide content at idle excessive |6.4.2c| | 1 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |6.4.2b| | 1 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |6.4.2b| | 1 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |6.4.2b| | 1 |
Exhaust mounting missing |7.1.1b| | 1 |
Rear Fuel pipe leaking |7.2.3| | 1 |
Centre Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Front Bonnet cannot be secured in the closed position |8.4.1| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Brake has no servo assistance |3.3.B.2| | 1 |
Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Offside Front Air suspension pipe leaking |2.4.D.2| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Emissions not tested |7.0| | 1 |
Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Front Electrical wiring insecure |1.9.2a| | 1 |
Offside Front Electrical wiring insecure |1.9.2a| | 1 |
Offside Rear Electrical wiring insecure |1.9.2a| | 1 |
Electrical wiring insecure |1.9.2a| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Rear fog lamp switch insecure |1.3.1a| | 1 |
Nearside Statutory seat belt missing |5.1.1| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
Windscreen wiper blade insecure | 1 |
Nearside Front Road wheel badly damaged |4.2.A.1a| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Bonnet cannot be secured in the closed position |8.4.1| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Offside Rear Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Offside Rear Service brake grabbing severely |3.7.C.2| | 1 |
Nearside Rear Service brake grabbing severely |3.7.C.2| | 1 |
Rear brake binding | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Vehicle structure has a fracture which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Vehicle structure has a fracture which adversely affects braking or steering |6.1.A.1| | 1 |
Steering column shaft locking device insecure |2.1.6| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Offside Front Steering box has excessive movement between sector shaft and the drop arm (2.1.3 (a) (ii)) | 1 |
Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
Offside Direction indicator not working Works intermittently (4.4.1 (a) (ii)) | 1 |
Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced At front cross member (6.1.1 (c) (i)) | 1 |
Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced At front cross member (6.1.1 (c) (i)) | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Battery insecure |1.9.1| | 1 |
Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front Passenger`s seat insecure NOT secured to floor |6.2.6 |a| |ii|| | 1 |
Stop lamp remains on when the brakes are released | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Offside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Fuel hose leaking |7.2.3| | 1 |
Steering box insecure |2.2.B.1a| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Rear fog lamp switch faulty |1.3.1a| | 1 |
Offside Front Axle king pin is loose in the axle beam |2.5.A.3a| | 1 |
Nearside Rear Lower Direction indicator not working |1.4.A.2c| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Front Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear Air suspension has no suspension movement |2.4.D.5| | 1 |
Offside Rear Hydraulic brake cylinder leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
Rear Brake valve leaking (1.1.7 (d) (i)) | 1 |
Front Exhaust system insecure rubber mounting split (6.1.2 (a)) | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Offside Rear Air suspension unit totally deflated |2.4.D.1a| | 1 |
Nearside Rear Air suspension unit totally deflated |2.4.D.1a| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Upper Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
Nearside Front Lower Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front Lower Horn not working |1.6.2a| | 1 |
Offside Front Upper Steering component mounting prescribed area is inadequately repaired |2.2.C.1h| | 1 |
Nearside Front Upper Exhaust engine idle speed too high |7.3.A.2a| | 1 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
Steering box has relative movement between sector shaft and the drop arm (2.1.3 (a) (i)) | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
All position lamps light intensity significantly reduced ALL POSITION LAMPS NOT WORKING (4.2.3 (a) (ii)) | 1 |
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Horn not working (7.7 (a)) | 1 |
Headlamp aim not tested (4.1.2 (b)) | 1 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
Rear Axle has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Electrical wiring inadequately supported |1.9.2a| | 1 |
Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Brake pipe inadequately supported |3.6.B.1| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Front Position lamp not working Both side (4.2.1 (a) (ii)) | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Front Battery insecure |1.9.1| | 1 |
Nearside Front Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
Offside Front Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Front Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Exhaust emits visible black smoke at idle |7.3.A.2b| | 1 |
Fuel hose leaking (6.1.3 (b) (i)) | 1 |
Offside Front Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Offside Lower Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
Nearside Rear Upper Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Brake cable has restricted free movement |3.5.1k| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |