| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 7 |
| Headlamp aim out of alignment | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Rear brake application uneven | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Brake pipe excessively corroded | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Wheel bolt|s| loose |4.2.A.1e| | 1 |
| Rear Rear reflector missing |1.5.1a| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Rear brake binding | 1 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Front Fuel system component leaking |7.2.3| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Body has a projection caused by damage |6.1.C.1| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front Braking system leaking |3.6.A.1| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Offside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |