| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 8 |
| Headlamp aim out of alignment | 4 |
| Registration plate issues | 4 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front All position lamps not working |1.1.A.3b| | 2 |
| Parking brake lever defective so that it cannot be satisfactorily operated |1.1.6 |d|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint front arm |2.4.G.2| | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Brake pipe leaking on a hydraulic braking system front to rear (1.1.11 (b) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength subframe (5.3.6 (a) (i)) | 1 |
| Suspension component mounting prescribed area excessively corroded significantly reducing structural strength nearside front subframe (5.3.6 (a) (i)) | 1 |
| Front Sub-frame corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point (6.1.1 (c) (i)) | 1 |
| Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point (6.1.1 (c) (i)) | 1 |
| Offside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Rear Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Offside Outer Rear Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Air suspension has no suspension movement |2.4.D.5| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill behind cover (6.1.1 (c) (i)) | 1 |
| Offside Rear Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill behind cover (6.1.1 (c) (i)) | 1 |
| Road wheel fixing missing one missing from each wheel (5.2.1 (a) (i)) | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Brake back plate|s| securing device loose |3.5.1j| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Offside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Nearside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Central Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |