| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Headlamp aim out of alignment | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Service brake: efficiency below requirements |3.7.C.1a| | 4 |
| Registration plate lamp issues | 3 |
| Brake pipe excessively corroded | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Brakes imbalanced across an axle | 2 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 2 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Stop lamp remains on when the brakes are released | 2 |
| Rear brake binding | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Seat belt missing receiver missing (7.1.2 (a)) | 1 |
| Offside Rear Seat belt missing receiver (7.1.2 (a)) | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Front Service brake grabbing severely |3.7.C.2| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Registration plate issues | 1 |
| Nearside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Rear Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Nearside Front Steering system excessively tight |2.2.D.1| | 1 |
| Offside Front Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Front Steering system excessively rough |2.2.D.1| | 1 |
| Offside Front Steering system excessively rough |2.2.D.1| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Nearside Front Leaf spring shackle pin locking device insecurely fitted |2.4.B.3b| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Brake linkage locking device missing |3.5.1l| | 1 |
| Emissions not tested |7.0| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is inadequately repaired |3.6.C.3| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Parking brake lever pawl spring does not push the pawl positively into the ratchet teeth |3.1.5| | 1 |
| Nearside Front Leaf spring splayed and fouling |2.4.B.1c| | 1 |
| Offside Front Leaf spring splayed and fouling |2.4.B.1c| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.B.1| | 1 |
| Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Windscreen wiper blade missing |8.2.2| | 1 |
| Position lamp switch insecure |1.1.A.1| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Front Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
| Offside Front Steering component mounting prescribed area is fractured |2.2.C.1h| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |