| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 11 |
| Headlamp aim out of alignment | 9 |
| Registration plate issues | 6 |
| Brake pipe excessively corroded | 5 |
| Brakes imbalanced across an axle | 4 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 4 |
| Exhaust emissions exceed level of metered smoke for a non-turbo charged engine (8.2.2.2 (b)) | 4 |
| Battery insecure |1.9.1| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Rear Stop lamp not working |1.2.1b| | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Fuel system component leaking |7.2.3| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Fuel system component leaking (6.1.3 (b) (i)) | 2 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Steering system excessively tight |2.2.D.1| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Horn not working |1.6.2a| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Rear brake binding | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Windscreen washer not working | 2 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 2 |
| Front brake application uneven | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Intermediate drop arm insecure |2.2.B.1a| | 2 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 2 |
| Registration plate lamp issues | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Front Prop shaft securing bolt loose (6.1.7 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chassis at leaf spring rear fixing (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chassis at leaf spring rear fixing (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Rear panel at leaf spring rear fixing (5.3.6 (a) (i)) | 1 |
| Offside Front Stub axle has excessive vertical movement between stub axle and axle beam (5.1.2 (c) (i)) | 1 |
| Nearside Rear Shock absorbers insecurely attached Lower fixing (5.3.2 (a) (i)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting cross member (6.1.6 (i) (i)) | 1 |
| Nearside Rear Lower Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting by bump stop (6.2.2 (d) (i)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Passenger`s seat insecure |6.2.A.1| | 1 |
| Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Statutory seat belt missing |5.1.1| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Rear Outer Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Rear Rear reflector missing |1.5.1a| | 1 |
| Brake hydraulic reservoir damaged and function impaired |3.6.A.2c| | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded by shock mount |2.4.A.3| | 1 |
| All direction indicators not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases rear section in half (6.1.2 (a)) | 1 |
| Service brake is causing the vehicle to swerve to the offside (1.2.1 (b) (i)) | 1 |
| Brake servo defective or ineffective (1.1.10 (a) (i)) | 1 |
| Rear Exhaust system insecure (6.1.2 (a)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Offside Front Vehicle structure has a fracture which adversely affects braking or steering |6.1.A.1| | 1 |
| Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Offside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Fuel tank insecure |7.2.1| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Headlamp aim projected beam image is obviously incorrect and low (4.1.2 (c)) | 1 |
| Central Rear Brake pipe leaking on a hydraulic braking system at junction on rear axle (1.1.11 (b) (ii)) | 1 |
| Brake performance unable to be tested Due to braking system condition (1.2.1 (g)) | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Upper Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Offside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 1 |
| Nearside Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Front Front wheel bearing has excessive play o/s and n/s |2.5.A.3c| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Steering box has relative movement to chassis/bodywork |2.1.2 |a| |ii|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Vehicle structure has damage which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Offside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |