Most common failures | No# failures |
---|
Headlamp aim out of alignment | 14 |
Brakes imbalanced across an axle | 11 |
Windscreen wiper does not clear the windscreen effectively | 11 |
Brake pipe excessively corroded | 11 |
Parking brake: efficiency below requirements |3.7.B.7| | 10 |
Registration plate lamp issues | 9 |
Registration plate issues | 7 |
Service brake: efficiency below requirements |3.7.B.7| | 6 |
Horn not working |1.6.2a| | 6 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 6 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
Parking brake lever has no reserve travel |3.1.6b| | 5 |
Offside Front Direction indicator not working |1.4.A.2c| | 5 |
Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 4 |
Nearside Front Direction indicator not working |1.4.A.2c| | 4 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Nearside Headlamp not working on main beam |1.7.5a| | 3 |
Fuel system component leaking |7.2.3| | 3 |
Nearside front brake binding |3.7.B.1| | 3 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Exhaust emits dense blue smoke at idle |7.4.A.1| | 3 |
Service brake: efficiency below requirements |3.7.C.1a| | 3 |
Rear brake binding | 3 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Stop lamp not working |1.2.1b| | 3 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Brake hose excessively deteriorated | 3 |
All position lamps not working |1.1.A.3b| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Fuel tank leaking |7.2.3| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Offside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 2 |
Nearside Rear reflector missing |1.5.1a| | 2 |
Offside Rear reflector missing |1.5.1a| | 2 |
Offside front brake recording little or no effort |3.7.B.5a| | 2 |
Exhaust emits clearly visible black smoke during acceleration |7.4.A2| | 2 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 2 |
Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Windscreen wiper blade insecure | 2 |
Offside Rear wheel bearing has excessive play |2.6.2| | 2 |
Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cross member |6.1.B.2| | 2 |
Rear brake application uneven | 2 |
Stop lamp remains on when the brakes are released | 2 |
Front passenger door does not latch securely closed |6.2.B.1a| | 2 |
Emissions not tested |7.0| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 2 |
Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 2 |
Offside Front Intermediate drop arm insecure |2.2.B.1a| | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Mechanical brake component has restricted free movement | 2 |
Exhaust emits excessive dense blue smoke during acceleration |7.4.A2| | 2 |
Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
Centre Exhaust system not adequately supported |7.1.1| | 2 |
Brake pedal spongy |3.3.B.1b| | 2 |
Offside Obligatory mirror missing |8.1.1| | 2 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Leaf spring shackle pin excessively loose in its bracket |2.4.B.3a| | 1 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Nearside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
Offside front brake juddering severely |3.7.A.2b| | 1 |
Offside Front Axle swivel joint has excessive play in a ball joint |2.5.A.3b| | 1 |
Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
Offside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Rear Exhaust mounting missing |7.1.1b| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Service brake indicates brake bind |3.7.D.2a| | 1 |
Offside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Towbar excessively corroded within 30cm of towbar mounting |6.1.6 |i| |i|| | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shocker mounting area |5.3.6 |a| |i|| | 1 |
Steering box has relative movement between sector shaft and the drop arm at lower spline to linkage |2.1.3 |a| |i|| | 1 |
Service brake is causing the vehicle to swerve to the nearside to the left |3.7.C.2| | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
Nearside Front Steering system fouling |2.2.D.2a| | 1 |
Offside Front Steering system fouling |2.2.D.2a| | 1 |
Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
Battery insecure |1.9.1| | 1 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |4.1.3 |b|| | 1 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front front brake recording little or no effort |3.7.B.5a| | 1 |
Brake has no servo assistance |3.3.B.2| | 1 |
Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
Rear Trailer electrical socket insecure |1.9.3a| | 1 |
Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Front Electrical wiring inadequately supported |1.9.2a| | 1 |
Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside Front Driver`s seat insecure |6.2.A.1| | 1 |
Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
Brake servo missing when fitted as standard |3.6.C.1a| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
Windscreen washer not working | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
Offside Front Steering box insecure |2.2.B.1a| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Intermediate drop arm insecure |2.2.B.1a| | 1 |
Steering box insecure |2.2.B.1a| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Steering wheel in a condition that hampers proper control |2.1.1| | 1 |
Nearside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
Offside Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
Offside Front Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
Nearside Rear reflector insecure |1.5.1a| | 1 |
Front Electrical wiring inadequately supported |1.9.2a| | 1 |
Front Electrical wiring insecure |1.9.2a| | 1 |
Centre Statutory seat belt missing |5.1.1| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Nearside Front Shock absorber insecure |2.7.2b| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Nearside Drag link end loose |2.2.B.1d| | 1 |
Offside Drag link end loose |2.2.B.1d| | 1 |
Nearside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
Brake rod locking device missing |3.5.1l| | 1 |
Electrical wiring insecure Under bonnet |1.9.2a| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded outrigger |2.4.A.3| | 1 |
Front brake application uneven | 1 |
Nearside Front Braking system leaking |3.6.A.1| | 1 |
Centre brake disc contaminated by oil |3.5.1h| | 1 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded front hanger |2.4.A.3| | 1 |
brake disc contaminated by oil |3.5.1h| | 1 |
Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Front Steering component mounting prescribed area is excessively corroded Chassis |2.2.C.1h| | 1 |
Front Steering component mounting prescribed area is inadequately repaired Chassis |2.2.C.1h| | 1 |
Nearside front brake grabbing severely |3.7.A.2b| | 1 |
Offside Rear Leaf spring shackle bracket corroded and seriously weakened |2.4.B.6d| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
All direction indicators not working |4.4.1 |a| |ii|| | 1 |
Offside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Offside engine mounting deteriorated resulting in excessive movement |6.1.D.1a| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
Exhaust emits visible black smoke at idle |7.4.A.1| | 1 |
Brake reservoir fluid level decreases after several pedal applications |3.3.C.1| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Exhaust has a major leak of exhaust gases Rear pipe |7.1.2| | 1 |
Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Nearside Front Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Obligatory mirror missing |8.1.1| | 1 |
Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Upper Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
brake drum contaminated by oil |3.5.1h| | 1 |
Rear Braking system leaking |3.6.A.1| | 1 |
Towbar component insecure |6.6.1| | 1 |
Rear Vehicle structure has excessive damage seriously affecting its strength within 30cm of a towbar mounting |6.6.6| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Nearside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Offside Inner Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Lower Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
Offside Front Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
Upper Brake clevis joint locking device missing |3.5.1l| | 1 |
Centre Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Upper Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Offside Front Seat belt flexible stalk cable has broken strands |5.2.4b| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Front Leaf spring fractured |2.4.B.1a| | 1 |
Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
Nearside Front Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
Offside Front Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
Nearside Rear Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
Offside Rear Leaf spring eye defective |shackle| |2.4.B.1b| | 1 |
Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |