Most common failures | No# failures |
---|
Headlamp aim out of alignment | 10 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Registration plate lamp issues | 6 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 6 |
Brake pipe excessively corroded | 5 |
Parking brake: efficiency below requirements |3.7.B.7| | 5 |
Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 4 |
Brakes imbalanced across an axle | 4 |
Brake pedal spongy |3.3.B.1b| | 4 |
Offside Stop lamp not working |1.2.1b| | 4 |
Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Registration plate issues | 4 |
Brake hose excessively deteriorated | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 3 |
Service brake: efficiency below requirements |3.7.C.1a| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 3 |
Indicator switch faulty |1.4.A.1| | 3 |
Offside Rear reflector missing |1.5.1a| | 3 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Rear Exhaust system not adequately supported |7.1.1| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 3 |
Rear brake binding | 3 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Hazard warning lamps inoperative |1.4.B.1b| | 2 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Brake pipe inadequately supported Front to rear |3.6.B.1| | 2 |
Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 2 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Fuel tank leaking |7.2.3| | 2 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Nearside Rear reflector missing |1.5.1a| | 2 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 2 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 2 |
Horn not working |1.6.2a| | 2 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Fuel system component insecure |7.2.1| | 2 |
Rear parking brake recording little or no effort | 2 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Nearside Front Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Statutory seat belt missing |5.1.1| | 1 |
Offside Statutory seat belt missing |5.1.1| | 1 |
Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Electrical wiring insecure |1.9.2a| | 1 |
Electrical wiring inadequately supported |1.9.2a| | 1 |
Horn control not readily accessible to the driver |1.6.1| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Statutory seat belt missing |5.1.1| | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Front Upper Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front Upper Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Rear Upper Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Rear Upper Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Nearside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Rear Lower Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Brake master cylinder/servo mounting prescribed area is inadequately repaired |3.6.C.3| | 1 |
Offside Rear Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
Fuel hose leaking |7.2.3| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Obligatory mirror missing |8.1.1| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Axle beam distorted |2.5.A.5b| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Nearside Rear Leaf spring damaged and permanently distorted |2.4.B.1a| | 1 |
Offside Rear Leaf spring damaged and permanently distorted |2.4.B.1a| | 1 |
Windscreen wiper blade insecure | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Nearside Rear front brake binding |3.7.B.1| | 1 |
Offside Rear front brake binding |3.7.B.1| | 1 |
Nearside Front Seat belt cut sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Offside Front Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Rear reflector missing |1.5.1a| | 1 |
Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Nearside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Front brake application uneven | 1 |
Nearside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Rear Direction indicator insecure |1.4.A.2b| | 1 |
Offside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Electrical wiring insecure |1.9.2a| | 1 |
Offside Rear Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Rear Exhaust mounting missing |7.1.1b| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Front Brake pipe excessively chafed |3.6.B.2c| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Horn control insecure |1.6.1| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Rear reflector missing |1.5.1a| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Prop shaft bearing excessively worn rear diff |6.1.7 |b| |i|| | 1 |
Prop shaft joint excessively worn both rears |6.1.7 |c| |i|| | 1 |
Front Prop shaft joint excessively worn |6.1.7 |c| |i|| | 1 |
Offside Rear Halfshaft securing bolt loose |6.1.7 |a| |i|| | 1 |
Nearside Rear Oil leaking excessively from transmission diff seal |8.4.1 |a| |i|| | 1 |
brake drum contaminated by oil Both rear |3.5.1h| | 1 |
Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Windscreen wiper control missing |8.2.1a| | 1 |
Windscreen washer control missing |8.2.1a| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Brake pedal feels spongy with the vacuum fully depleted |3.3.C.2| | 1 |
Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Rear Exhaust has a major leak of exhaust gases box (6.1.2 (a)) | 1 |
Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Offside Front Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Offside Front Brake servo insecurely mounted |3.6.A.2a| | 1 |
Rear Body has excessive displacement which may lead to loss of vehicle control |6.1.B.1a| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Rear Exhaust has a major leak of exhaust gases tail pipe |7.1.2| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Front wheel bearing has excessive play o/s and n/s |2.5.A.3c| | 1 |
Offside Front Intermediate drop arm insecure |2.2.B.1a| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Front Horn not working |1.6.2a| | 1 |
Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Nearside Front Direction indicator incomplete |1.5.A1b| | 1 |
Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Shock absorber insecure |2.7.2b| | 1 |
Offside Outer Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Battery insecure |1.9.1| | 1 |
Nearside Direction indicator not working |1.4.A.2c| | 1 |
Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Hazard warning lamps operated by more than one switch |1.4.B.1c| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Lower Steering column shaft repaired by welding |2.2.C.1e| | 1 |
Lower Steering column repaired by welding |2.2.C.1e| | 1 |
Lower Steering column shaft deformed and unserviceable |2.2.C.1d| | 1 |
Lower Steering column shaft has had excessive heat applied |2.2.C.1e| | 1 |
Centre Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Centre Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Front Fuel system component leaking |7.2.3| | 1 |
Nearside Rear Leaf spring shackle bracket loose |2.4.B.6a| | 1 |