| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 22 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 12 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 10 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 9 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Registration plate lamp issues | 8 |
| Brakes imbalanced across an axle | 8 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 6 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Horn not working |1.6.2a| | 5 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 5 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Rear brake binding | 5 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Registration plate issues | 4 |
| Nearside Rear reflector missing |1.5.1a| | 4 |
| Service brake: efficiency below requirements |3.7.C.1a| | 4 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 3 |
| Brake pipe excessively corroded | 3 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 3 |
| Indicator tell tale inoperative |1.4.A.2a| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 3 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 3 |
| Exhaust emits clearly visible black smoke during acceleration |7.4.A2| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Offside Front Leaf spring to axle securing nut insecure |2.4.B.7b| | 2 |
| Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Brake master cylinder/servo mounting prescribed area is inadequately repaired |3.6.C.3| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear reflector missing |1.5.1a| | 2 |
| Battery insecure |1.9.1| | 2 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Exhaust emits excessive dense blue smoke during acceleration |7.4.A2| | 2 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Steering system excessively tight |2.2.D.1| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
| Indicator switch insecure |1.4.A.1| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Headlamp insecure |1.7.3| | 2 |
| Nearside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 2 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 2 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Front Leaf spring to axle securing nut insecure |2.4.B.7b| | 2 |
| Front brake application uneven | 2 |
| Rear Drive shaft uj which forms part of the suspension has a loose flange bolt |2.4.G.4c| | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Offside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Outer Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Brake hose twisted |3.6.B.4c| | 1 |
| Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Nearside Front Leaf spring eye defective |anchor| |2.4.B.1b| | 1 |
| Offside Front Leaf spring eye defective |anchor| |2.4.B.1b| | 1 |
| Offside Front Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Nearside Front Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Nearside Inner Front Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Offside Inner Front Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Mechanical brake component securing device loose |3.5.1i| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Brake hose inappropriately repaired |3.6.A.3| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear reflector more than 50% obscured |1.5.1b| | 1 |
| Offside Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front brake drum contaminated by oil |3.5.1h| | 1 |
| Offside Front brake drum contaminated by oil |3.5.1h| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Offside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Headlamp switch insecure |1.7.1| | 1 |
| Front Headlamp not working on dipped beam both |1.7.5a| | 1 |
| Front Headlamp not working on main beam both |1.7.5a| | 1 |
| Stop lamp not working both |1.2.1b| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Nearside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
| Nearside Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
| Offside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Centre brake drum contaminated by oil |3.5.1h| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Upper Steering pivot point has excessive play |2.2.B.1g| | 1 |
| brake drum insecure |3.5.1i| | 1 |
| Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Exhaust emits dense blue smoke at idle |7.4.A.1| | 1 |
| Nearside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Lower Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Offside Front Upper Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Front Lower Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Fuel pipe union leaking |7.2.3| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Nearside Front Axle beam has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Passenger compartment passenger compartment in such a condition that it permits the entry of exhaust fumes (6.2.1 (c) (i)) | 1 |
| Front Electrical wiring insecure and connectors likely to become disconnected (4.11 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam on main beam when on dip (4.1.1 (a) (ii)) | 1 |
| Position lamp switch does not illuminate the front and rear position lamps with a single operation (4.2.2 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Exhaust fumes entering cabin |6.1.2 |b| |i|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Electrical wiring insecure and connectors likely to become disconnected |4.11 |a| |ii|| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Position lamp switch does not illuminate the front and rear position lamps with a single operation |4.2.2 |a|| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Electrical wiring inadequately supported |1.9.2a| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Leaf spring shackle pin or bush excessively worn REAR BUSH (5.3.4 (a) (i)) | 1 |
| Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Central Rear Body mounting fixings insecure such that stability is seriously impaired cross member (6.2.2 (c) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Brake hydraulic reservoir leaking hydraulic fluid |3.6.A.1| | 1 |
| Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Direction indicators not in good working order |function impaired| |1.5.A1b| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Offside Front brake drum contaminated by brake fluid |3.5.1h| | 1 |
| Parking brake lever has excessive side play in the pivot and may disengage |3.1.4a| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Upper Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Nearside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced near to bump stop (6.1.1 (c) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Fuel system component leaking at filter, lift pump and tank drain plug (6.1.3 (b) (i)) | 1 |
| Nearside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
| Front Leaf spring shackle pin or bush excessively worn both side front spring rear bushes and pins (5.3.4 (a) (i)) | 1 |
| Service brake is causing the vehicle to swerve to the offside (1.2.1 (b) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Service brake is causing the vehicle to swerve to the offside |1.2.1 |b| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Offside Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Nearside Front Leaf spring linkage pin excessively loose in its bracket |2.4.B.3a| | 1 |
| Front Front position lamp|s| not working x2 |1.1.A.3b| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Nearside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Centre Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
| Offside Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |