| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Brakes imbalanced across an axle | 12 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 7 |
| Horn not working |1.6.2a| | 6 |
| Rear brake binding | 6 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Offside Headlamp not working on main beam |1.7.5a| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Brake pipe excessively corroded | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Rear brake application uneven | 3 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Front Direction indicator not working |1.4.A.2c| | 3 |
| Direction indicators not working |1.4.A.2c| | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 2 |
| Rear Brake hose bulging under pressure |3.6.B.3| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Offside Front front brake binding |3.7.B.1| | 2 |
| Offside Rear brake drum contaminated by oil |3.5.1h| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Service brake is causing the vehicle to swerve to the nearside (1.2.1 (b) (i)) | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Stop lamp remains on when the brakes are released | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Front Intermediate drop arm insecure |2.2.B.1a| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 2 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Nearside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Upper Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Access panel cannot be secured in the closed position |6.4.1| | 1 |
| Offside Front Access panel cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Centre Front Hand operated control valve unit insecure |3.2.2a| | 1 |
| Offside Front Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Electrical wiring inadequately supported engine bay live from battery |1.9.2a| | 1 |
| Offside Front Steering retaining device missing ball joint splitpin missing |2.2.C.1g| | 1 |
| Brake hose damaged | 1 |
| Electrical wiring inadequately supported wires rubbing on steering arm from box |1.9.2a| | 1 |
| Nearside Front Wheel hub spigot mounting excessively worn |4.2.B.5| | 1 |
| Offside Front Wheel hub spigot mounting excessively worn |4.2.B.5| | 1 |
| Nearside Front Track rod end loose |2.2.B.1d| | 1 |
| Steering retaining device missing |2.2.C.1g| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Windscreen washer control missing |8.2.1a| | 1 |
| Nearside Front Service brake excessively binding off side front (1.2.1 (f)) | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Registration plate lamp issues | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Front brake application uneven | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Suspension spring mounting prescribed area is fractured chassis leg |2.4.A.3| | 1 |
| Nearside Windscreen has a combination of minor damage areas which restrict the drivers view |8.3.1c| | 1 |
| Steering column universal joint has excessive play At steering box |2.1.5| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Windscreen wiper control missing |8.2.1a| | 1 |
| Headlamp not working on dipped beam both |1.7.5a| | 1 |
| Headlamp not working on main beam both |1.7.5a| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Offside Front front brake recording little or no effort |3.7.B.5a| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint Front u/j |2.4.G.4b| | 1 |
| Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint Rear u/j |2.4.G.4b| | 1 |
| Centre Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Brake servo leaking |3.6.C.1c| | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Rear Brake lining(s) contaminated BOTH SIDES (1.1.13 (b)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Rear Axle insecure such that stability is impaired (U) bolts loose (5.1.1 (b) (ii)) | 1 |
| Nearside Rear Brake master cylinder leaking (1.1.10 (b) (ii)) | 1 |
| Offside Rear Brake master cylinder leaking (1.1.10 (b) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced A pillar- outer near upper and lower door hinge attachment (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced a pillar- inner top door hinge (6.1.1 (c) (i)) | 1 |
| Offside Front Wheel bearing play so excessive it is likely to break up |5.1.3 |a| |ii|| | 1 |
| Offside Front Electrical wiring insulation in such a condition there is an imminent risk of fire or formation of sparks |4.11 |c| |iii|| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Drag link end seriously misaligned |2.2.C.1b| | 1 |
| Nearside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Offside Front Statutory seat belt of the wrong type. |5.1.1| | 1 |
| Registration plate issues | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Parking brake lever, pawl mechanism pivot|s| retaining device insecure |3.1.4b| | 1 |
| Nearside Front Outer Drag link end loose |2.2.B.1d| | 1 |
| Steering wheel weakened by fractures |2.1.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Offside Front Upper Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Brake master cylinder leaking (1.1.10 (b) (ii)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Brake fluid significantly below minimum mark (1.1.10 (d) (ii)) | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Rear Service brake effort inadequate at a wheel both rear wheels |1.2.1 |a| |i|| | 1 |
| Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
| Brake fluid significantly below minimum mark |1.1.10 |d| |ii|| | 1 |
| Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Parking brake lever releases when knocked |3.1.6a| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front Brake pipe fouled by moving parts steering arm |3.6.B.2a| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Rear Wheel stud|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front Windscreen wiper control missing |8.2.1a| | 1 |
| Front Windscreen washer control missing |8.2.1a| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Brake servo vacuum pipe collapsed |3.6.C.1b| | 1 |
| Brake vacuum build up too slow |3.3.E.6| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Centre Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings front cross member |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings body mountings and above |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings body mountings and above |6.1.B.2| | 1 |
| Offside Front Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Brake pivot excessively worn and seriously weakened |3.5.1e| | 1 |
| Offside Front Brake relay lever locking device insecure |3.5.1l| | 1 |
| Nearside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Drag link end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Offside Front Upper Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Offside Front Lower Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Offside Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Nearside Front Leaf spring anchor bracket cracked |2.4.B.6b| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Lower Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |