| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 11 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 9 |
| Headlamp aim out of alignment | 8 |
| Registration plate issues | 7 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Brake hose damaged | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 2 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Suspension system inoperative (5.3.5 (a)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| Nearside Rear Lower Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Front Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front Hydraulic brake cylinder retaining device missing |3.6.A.2d| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Road wheel cracked |4.2.A.1a| | 1 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Outer Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Outer Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front brake application uneven | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Nearside Front Brake performance not tested badly corroded brake pipe (1.2.1 (g)) | 1 |
| Nearside Front Brake pipe at imminent risk of failure or fracture (1.1.11 (a)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Rear Exhaust shield missing where fitted as original equipment creating a risk of fire (6.1.3 (e)) | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Front Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint front |2.4.G.2| | 1 |
| Nearside Rear Position lamp lens seriously defective (4.2.1 (b)) | 1 |
| Offside Front Bumper insecure (6.1.4 (a) (i)) | 1 |
| Nearside Front Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Front Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Central Rear Seat belt not functioning as intended (7.1.2 (c)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Windscreen damaged and affecting the drivers view of the road (3.2 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Emissions not tested engine misfire (8.2.1.2 (d)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Central Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
| Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |