| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 20 |
| Brake pipe excessively corroded | 15 |
| Registration plate lamp issues | 10 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Anti-lock braking system warning lamp indicates an ABS fault | 9 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 8 |
| Brake hose excessively deteriorated | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 5 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Steering column will not lock in a fixed position |adjustable type| |2.1.2a| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Front Sub-frame corroded and seriously weakened |2.4.G.1| | 2 |
| Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 2 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement rear of the two |2.4.G.2| | 1 |
| Nearside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Offside Rear Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Nearside Rear Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Rear Suspension arm attachment bracket/mounting nut missing |2.4.G.1| | 1 |
| Brake fluid significantly below minimum mark |1.1.10 |d| |ii|| | 1 |
| Offside Rear Brake pipe leaking on an air braking system |1.1.11 |b| |i|| | 1 |
| Emissions not tested Due to excessive brake fluid leaking |8.2.1.2 |d|| | 1 |
| Brake performance not tested Due to excessive brake fluid leaking |1.2.1 |g|| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front Steering damper leaking oil |2.2.C.1f| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Registration plate issues | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt rubber missing |5.3.4 |b| |ii|| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Brake back plate|s| securing device loose |3.5.1j| | 1 |
| Offside Front Brake back plate|s| securing device loose |3.5.1j| | 1 |
| Brake hose damaged | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Anti-lock braking system warning lamp sequence is incorrect |3.4.1d| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush oter rose joint |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush outer rose joint |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush as above |2.4.G.2| | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Outer Drive shaft which forms part of the suspension coupling gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
| Front Power steering pipe|s| or hose|s| excessively corroded below radiator |2.3.2| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Radius arm rubber bush deteriorated resulting in excessive movement both bushes |chalked |2.4.G.2| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Headlamp cleaning device obviously defective |1.7.2| | 1 |
| Offside Rear Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Offside Rear Upper Radius arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Rear Direction indicator incorrect colour both sides (4.4.3 (a)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2) | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a) | 1 |
| Parking brake: efficiency below requirements (3.7.C.1b) | 1 |
| Steering column will not lock in a fixed position (adjustable type) (2.1.2a) | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.B.1b) | 1 |
| Offside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.4.G.2) | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2) | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bearing (2.4.G.2) | 1 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bearing (2.4.G.2) | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2) | 1 |
| Offside Front position lamp(s) not working (1.1.A.3b) | 1 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a) | 1 |
| Windscreen has damage | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Suspension system inoperative (5.3.5 (a)) | 1 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn rose bush chalked (5.3.4 (a) (i)) | 1 |
| Offside Rear Upper Suspension arm pin or bush excessively worn rose bush chalked (5.3.4 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust fumes causing a danger to health of persons on board (6.1.2 (b) (ii)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn hub bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn hub bush (5.3.4 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases middle section (6.1.2 (a)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Nearside Front Brake hose excessively damaged Rigid abs wire rubbing hose (1.1.12 (b) (ii)) | 1 |