Most common failures | No# failures |
---|
Headlamp aim out of alignment | 17 |
Offside Rear fog lamp not working |1.3.2b| | 14 |
Horn not working |1.6.2a| | 11 |
Registration plate lamp issues | 11 |
Brake hose excessively deteriorated | 10 |
Windscreen wiper does not clear the windscreen effectively | 9 |
Rear fog lamp tell tale not working |1.3.1b| | 8 |
Brake pipe excessively corroded | 8 |
Registration plate issues | 8 |
Nearside Front Direction indicator not working |1.4.A.2c| | 6 |
Rear parking brake recording little or no effort | 6 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Parking brake lever has no reserve travel |3.1.6b| | 5 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 5 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 4 |
Nearside Side repeater not working |1.4.A.2c| | 4 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 4 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 3 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 3 |
Parking brake: efficiency below requirements |3.7.B.7| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 3 |
Windscreen wiper blade insecure | 3 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Front brake disc in such a condition that it is seriously weakened | 3 |
Offside Side repeater not working |1.4.A.2c| | 3 |
Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
Fuel tank leaking |7.2.3| | 3 |
Offside Headlamp not working on main beam |1.7.5a| | 3 |
Rear fog lamp not working |1.3.2b| | 3 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Offside Rear Direction indicator not working |1.4.A.2c| | 3 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 3 |
Power steering component|s| leaking |2.3.3b| | 3 |
Intermediate drop arm insecure |2.2.B.1a| | 2 |
Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Brakes imbalanced across an axle | 2 |
Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Side repeater not working |1.4.A.2c| | 2 |
Steering box insecure |2.2.B.1a| | 2 |
Offside Front brake disc contaminated by oil |3.5.1h| | 2 |
Offside Front Power steering component|s| leaking |2.3.3b| | 2 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
Offside Rear brake disc contaminated by oil |3.5.1h| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Horn not loud enough to be heard by another road user |1.6.2b| | 2 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Mechanical brake component has restricted free movement | 2 |
Bonnet cannot be secured in the closed position |8.4.1| | 2 |
Brake hose damaged | 2 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 2 |
Offside Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
Power steering pump leaking from a failed component |2.3.3b| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 2 |
An item not tested |Manual| | 2 |
Steering pivot point has excessive play |2.2.B.1g| | 2 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Power steering malfunctioning |2.3.3a| | 2 |
Centre Exhaust system not adequately supported |7.1.1| | 2 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Position lamp switch faulty |1.1.A.1| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Emissions not tested |7.0| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Outer Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Steering wheel retaining device insecure |2.1.6| | 1 |
Steering locking device missing |2.2.C.1g| | 1 |
Offside Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt str/box drop arm ball joint cover |2.1.3 |g| |ii|| | 1 |
Front Suspension rod pin or bush excessively worn 1st axle stabiliser rod |5.3.4 |a| |i|| | 1 |
Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Side repeater incorrect colour nearside and offside bulbs faded |4.4.3 |a|| | 1 |
Offside Front Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear reflector missing |1.5.1a| | 1 |
Offside Rear reflector missing |1.5.1a| | 1 |
Power steering inoperative |2.3.3a| | 1 |
Steering box has a significant oil leak |2.2.D.2e| | 1 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Offside Rear Service brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Rear Parking brake: efficiency below requirements |3.7.B.7| | 1 |
Nearside Steering locking device missing |2.2.C.1g| | 1 |
Parking brake efficiency below requirements |3.7.E.1| | 1 |
Nearside Front Drag link end ball joint has excessive play rear arm |2.2.B.1f| | 1 |
Offside Front Drag link end ball joint has excessive play front arm connecting to steering box |2.2.B.1f| | 1 |
Offside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
Nearside Front Side repeater excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Offside Stop lamp excessively deteriorated so that it is not visible from a reasonable distance |1.2.1d| | 1 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded a pillar |2.4.A.3| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded a pillar |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is inadequately repaired a pillar |2.4.A.3| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt front |2.2.C.1c| | 1 |
Front position lamp|s| adversely affected by the operation of another lamp when brake pedal is depressed |1.1.A.3f| | 1 |
Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Rear brake binding | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Outer Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Brake master cylinder/servo mounting prescribed area is inadequately repaired |3.6.C.3| | 1 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Offside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Power steering pump leaking from a failed joint |2.3.3b| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Shock absorber insecure |2.7.2b| | 1 |
Centre Statutory seat belt missing |5.1.1| | 1 |
Offside Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Centre Front passenger seat insecure |6.2.3| | 1 |
Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Front suspension has excessive play in a upper wishbone bearing |2.5.B.1a| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Offside Rear Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Offside Rear Axle has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Nearside Rear Axle has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Power steering pipe|s| or hose|s| excessively corroded |2.3.2| | 1 |
Nearside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Front Steering arm damaged and unserviceable |2.2.C.1d| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Front brake application uneven | 1 |
Offside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Offside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Headlamp switch faulty |1.7.1| | 1 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
Offside Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Front Lower Steering column universal joint has excessive play |2.1.5| | 1 |
Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Lower Steering column universal joint has excessive play |2.1.5| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Side repeater incomplete |1.5.A1b| | 1 |
Power steering pump leaking from a failed seal |2.3.3b| | 1 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Centre Front Statutory seat belt missing |5.1.1| | 1 |
Centre Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Offside Ball joint has excessive play |2.2.B.1f| | 1 |
Power steering component|s| leaking from a failed joint |2.3.3b| | 1 |
Nearside Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Upper Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Centre Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Rear Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Rear passenger seat cannot be secured in the upright position. |6.2.3| | 1 |
Nearside Front brake disc contaminated by oil |3.5.1h| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Offside Front Upper Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Lower Panhard rod rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Brake pipe kinked |3.6.B.2b| | 1 |
Nearside Front Brake pipe kinked |3.6.B.2b| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Nearside Front Upper Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Lower Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Front Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Steering component is not secure to the vehicle structure |2.2.B.1a| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Rear coil spring worn so that its cross sectional area is reduced and seriously weakened |2.4.C.1b| | 1 |
Rear Exhaust mounting missing |7.1.1b| | 1 |
Offside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
Nearside Rear Lower Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
Offside Rear Lower Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
Offside Body mounting fixings insecure body brackets cracked (6.2.2 (c) (i)) | 1 |
All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Windscreen wiper not working (3.4 (a)) | 1 |
Windscreen washer not working | 1 |
Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt drop arm (2.1.3 (g) (ii)) | 1 |
Offside Suspension rod pin or bush excessively worn panhard rod (5.3.4 (a) (i)) | 1 |
Suspension arm pin or bush excessively worn both front trailing arms (5.3.4 (a) (i)) | 1 |
Offside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |