| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 27 |
| Registration plate lamp issues | 18 |
| Brake pipe excessively corroded | 17 |
| Brakes imbalanced across an axle | 10 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 7 |
| Registration plate issues | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Rear brake binding | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 6 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Offside Headlamp not working on main beam |1.7.5a| | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Horn not working |1.6.2a| | 5 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Nearside Stop lamp not working |1.2.1b| | 4 |
| Front brake application uneven | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Rear fog lamp missing |1.3.2a| | 4 |
| Nearside Rear Stop lamp not working |1.2.1b| | 4 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Offside Rear reflector missing |1.5.1a| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Stop lamp not working |1.2.1b| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Offside Front Direction indicator not working |1.4.A.2c| | 2 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake hose excessively deteriorated | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Indicator switch faulty |1.4.A.1| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 2 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 2 |
| Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Indicator tell tale inoperative |1.4.A.2a| | 2 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Centre Statutory seat belt missing |5.1.1| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Windscreen washer not working | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Front brake excessively fluctuating | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Front passenger seat cannot be secured in the upright position. |6.2.4| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear reflector missing |1.5.1a| | 1 |
| Obligatory mirror insecure |8.1.1| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Rear reflector not red in colour |1.5.1d| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Seat belt stitching not secure |5.2.2b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear wheel cylinder has restricted free movement |3.5.1k| | 1 |
| Offside Front Headlamp are incorrectly positioned out of focus no pattern |4.1.4 |a|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Fuel system component leaking excessively or a risk of fire |6.1.3 |b| |ii|| | 1 |
| Nearside Rear Brake drum contaminated oil leaking out axle over brakes |1.1.14 |b|| | 1 |
| Nearside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Axle swivel joint insecure in a stub axle |2.5.A.3b| | 1 |
| Brake master cylinder fluid level below minimum level |3.6.G.1e| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Service brake grabbing severely |3.7.C.2| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Offside Front wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Front brake drum contaminated by brake fluid |3.5.1h| | 1 |
| All position lamps not working |4.2.1 |a|| | 1 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Floor viewed from inside wheel arch. |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Chassis outrigger. |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Chassis outrigger. |6.1.B.2| | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Nearside Rear Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| All direction indicators not working |4.4.1 |a| |ii|| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Centre Front Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 1 |
| Nearside Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
| Windscreen has damage | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Steering locking device insecure |2.2.C.1g| | 1 |
| Nearside front brake juddering severely |3.7.A.2b| | 1 |
| Offside front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Front Seat belt attachment fitting badly deteriorated |5.2.3| | 1 |
| Emissions not tested |7.0| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Brake master cylinder/servo mounting prescribed area is inadequately repaired |3.6.C.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Front Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Steering component mounting prescribed area is inadequately repaired |2.2.C.1h| | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear reflector missing |1.5.1a| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Fuel pipe leaking |7.2.3| | 1 |
| Nearside Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Leaf spring shackle bracket nut missing |2.4.B.6c| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Brake pipe inadequately supported to rear |3.6.B.1| | 1 |
| Rear Towbar locking device insecure |6.6.3b| | 1 |
| Nearside Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded xmember |2.4.A.3| | 1 |
| Brake pipe leaking front to rear pipe |3.6.A.1| | 1 |
| Position lamp switch cannot be operated from the normal driving position |1.1.A.1| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Brake pedal does not operate a brake fitted to each wheel |3.3.A.3| | 1 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Front Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Front Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced near spring hanger |6.1.1 |c| |i|| | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced near spring hanger |6.1.1 |c| |i|| | 1 |
| Nearside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Brake lever has restricted free movement |3.5.1k| | 1 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded wheel arch |3.6.C.3| | 1 |
| Offside Brake actuating linkage mounting prescribed area is excessively corroded wheel arch/pedal box mounting |3.3.A.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outrigger |6.1.B.2| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front front brake grabbing severely |3.7.A.2b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Rear Leaf spring eye defective |anchor| |2.4.B.1b| | 1 |
| Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Brake pipe inadequately supported |3.6.B.1| | 1 |
| Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Seat belt installation has an anchorage without suitable reinforcement small shackle used to mount seat belt (10.1 (f)) | 1 |
| Nearside Front Seat belt installation has an anchorage without suitable reinforcement small shackle used to mount seat belt (10.1 (f)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Intermediate drop arm insecure to the extent there is excessive movement at the mountings pivot clamp bolt loose (2.1.3 (a) (ii)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired Footwell/bulkhead (6.2.2 (d) (ii)) | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams (4.1.3 (b)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Integral body structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
| Headlamp not working on dipped beam both (4.1.1 (a) (ii)) | 1 |
| Offside Front Hydraulic fluid leaking excessively (8.4.1 (a) (i)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |