| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 8 |
| Registration plate lamp issues | 7 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Registration plate issues | 3 |
| Horn not working |1.6.2a| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Windscreen washer not working | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Rear Mechanical brake component has restricted free movement | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Hazard warning lamps inoperative |1.4.B.1b| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chassis (5.3.6 (a) (i)) | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded Bulk head (1.1.21 (e) (i)) | 1 |
| Offside Rear Wheel bearing play so excessive that directional control is impaired |5.1.3 |a| |ii|| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Centre Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded crossmember in front of fuel tank. |2.4.A.3| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded chassis member at mount for rear axle tie bar. |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded chassis member at mount for rear axle tie bar. |2.4.A.3| | 1 |
| Offside Front Front suspension has excessive movement at a tie bar joint behind axle. |2.5.A.1c| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer face of crossmember. |6.1.B.2| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded chassis central at mount for rear axle tie bar. |2.4.A.3| | 1 |
| Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded chassis central at mount for rear axle tie bar. |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded at mount for front axle tie bar. |2.4.A.3| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings crossmember underneath. |6.1.B.2| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Steering damper excessively corroded and unserviceable on front axle |2.2.C.1d| | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer intake pipe |7.1.2| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded axle steady on chassis |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded rear axle steady mount on chassis |2.4.A.3| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings crossmember |6.1.B.2| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Rear Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Rear Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Semaphore indicator tell tale not working correctly |1.4.C.2| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Front Electrical wiring likely to touch hot or rotating parts (4.11 (a) (iii)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Nearside Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Offside Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Steering column attachment defective (2.2.2 (d) (i)) | 1 |
| Steering column universal joint has excessive wear or play (2.2.2 (c)) | 1 |
| Power steering malfunctioning (2.1.5 (a)) | 1 |
| Power steering pump leaking (2.1.5 (a)) | 1 |
| Power steering component leaking (2.1.5 (a)) | 1 |
| Nearside Rear Coil spring insecure (5.3.1 (a) (i)) | 1 |
| Offside Rear Coil spring insecure (5.3.1 (a) (i)) | 1 |
| Nearside Rear Halfshaft securing bolt missing (6.1.7 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Offside Front Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Front passenger door does not latch securely closed |6.2.3 |a|| | 1 |
| Fluid leaking continuously posing a serious risk to road safety diesel leak |8.4.1 |a| |ii|| | 1 |
| Nearside Rear Halfshaft securing bolt loose 3 bolts loose |6.1.7 |a| |i|| | 1 |
| Offside Rear Halfshaft securing bolt loose 1 bolt loose |6.1.7 |a| |i|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Fuel pipe leaking feed pipe union from filter to pump |7.2.3| | 1 |
| Nearside Windscreen wiper blade missing |8.2.2| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Brake pipe excessively corroded | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.4.B.1| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Nearside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Central Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Steering linkage ball joint ball joint dust cover insecure so that it no longer prevents the ingress of dirt drop arm (2.1.3 (g) (ii)) | 1 |
| Offside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Radius arm has excessive play in a pin/bush both |2.4.G.2| | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Towbar component insecure |6.6.1| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |