| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 19 |
| Registration plate issues | 6 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Brake pipe excessively corroded | 4 |
| Registration plate lamp issues | 3 |
| Horn not working |1.6.2a| | 3 |
| Brake hose excessively deteriorated | 3 |
| Service brake: efficiency below requirements |3.7.C.1a| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 3 |
| Rear Stop lamp not working |1.2.1b| | 2 |
| Hazard warning switch faulty |1.4.B.1d| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Position lamp switch faulty |1.1.A.1| | 2 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 2 |
| Offside Front Panhard rod has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Lower Steering column universal joint has excessive play |2.1.5| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Offside Rear Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Steering column excessively corroded and unserviceable |2.2.C.1d| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Windscreen washer control missing |8.2.1a| | 1 |
| Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded Are of rear trailing arm mount on chassis. |2.4.A.3| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Parking brake lever, pawl mechanism pivot|s| or their associated mountings locking device insecure |3.1.4b| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Rear Seat belt insecurely fixed to the vehicles structure and buckle locking tab siezed allowing belt to detach |5.2.1a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Stop lamp not working both |1.2.1b| | 1 |
| Offside Rear reflector missing |1.5.1a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Headlamp not working on dipped beam both |1.7.5a| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded t/arm mount area |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded t/am mount area |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded end of x/member to front of s/ab |2.4.A.3| | 1 |
| Nearside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Offside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
| Nearside Front Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Steering locking device missing drag link at st box split pin missing |2.2.C.1g| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Rear Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Inner Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Panhard rod attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Panhard rod rubber mounting bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Upper Steering column universal joint has excessive play |2.1.5| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Drag link end ball joint has excessive play from steering box (2.1.3 (b) (i)) | 1 |
| Steering box fixing bolts ineffective steering arm shocker leaking (2.1.2 (c) (i)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Exhaust fumes entering cabin rear exhaust missing (6.1.2 (b) (i)) | 1 |
| All direction indicators not working all (4.4.1 (a) (ii)) | 1 |
| Offside Rear Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting crossmember (6.2.2 (d) (i)) | 1 |
| Offside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting crossmember (6.2.2 (d) (i)) | 1 |
| Nearside Front Outer Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting out rigger (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced floor (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced floor (6.1.1 (c) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Offside Track rod end loose |2.2.B.1d| | 1 |
| Front Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Front Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
| Offside Front Brake back plate|s| securing device missing |3.5.1j| | 1 |
| Offside Rear Brake back plate|s| securing device missing |3.5.1j| | 1 |
| Nearside Rear Brake back plate|s| securing device missing |3.5.1j| | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
| Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Suspension arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Power steering ram|s| leaking from a failed seal |2.3.3b| | 1 |
| Nearside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Nearside Front Trailing arm attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Nearside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Hazard warning lamps operated by more than one switch |1.4.B.1c| | 1 |
| Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Front Front suspension retaining device ineffective |2.5.A.4| | 1 |
| Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Lower Steering box has excessive free play detected at the steering wheel |steering box fitted| |2.3 |a| |i|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Steering arm damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Front Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Electrical wiring insecure |1.9.2a| | 1 |
| Position lamp switch insecure |1.1.A.1| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Offside Rear Lower Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Electrical wiring insecure |1.9.2a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |