| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 57 |
| Brake pipe excessively corroded | 38 |
| Windscreen wiper does not clear the windscreen effectively | 29 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 24 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 24 |
| Registration plate lamp issues | 18 |
| Offside Rear fog lamp not working |1.3.2b| | 15 |
| Rear fog lamp not working |1.3.2b| | 15 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 15 |
| Registration plate issues | 14 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 11 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 8 |
| Service brake: efficiency below requirements |3.7.B.7| | 8 |
| Offside Stop lamp not working |1.2.1b| | 7 |
| Offside Rear Stop lamp not working |1.2.1b| | 6 |
| Offside Side repeater not working |1.4.A.2c| | 6 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 5 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 5 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 5 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 5 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 4 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Windscreen washer not working | 4 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 4 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 4 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 4 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 4 |
| Rear brake disc in such a condition that it is seriously weakened | 4 |
| Horn not working (7.7 (a)) | 3 |
| Nearside Rear Stop lamp not working |1.2.1b| | 3 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 3 |
| Nearside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 3 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 3 |
| Offside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
| Exhaust catalytic converter missing where one was fitted as standard |7.1.3| | 3 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 3 |
| Service brake: efficiency below requirements |3.7.C.1a| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 3 |
| Nearside Rear Statutory seat belt missing |5.1.1| | 3 |
| Offside Rear Statutory seat belt missing |5.1.1| | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 3 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 2 |
| Offside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 2 |
| Speedometer cannot be illuminated |7.8 |c| |ii|| | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 2 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 2 |
| Horn sound not in accordance with requirements (7.7 (c)) | 2 |
| Brake performance not tested (1.2.1 (g)) | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Rear fog lamp obscured more than 50% |1.3.2c| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Rear Rear fog lamp not working |1.3.2b| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Nearside Rear reflector missing |1.5.1a| | 2 |
| Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 2 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 2 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 2 |
| Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Ball joint has excessive play |2.2.B.1f| | 2 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Windscreen wiper blade insecure | 2 |
| Offside Rear Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 1 |
| Nearside Rear Inner Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Inner Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength turret corroded (5.3.6 (a) (i)) | 1 |
| Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis has hole caused by corrosion. (6.1.1 (c) (i)) | 1 |
| Offside Rear Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Central Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Exhaust has a part missing |7.1.1a| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Emissions not tested |7.0| | 1 |
| Emissions not tested too high (8.2.1.2 (d)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced rear (6.1.1 (c) (i)) | 1 |
| Rear Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Steering system fouling Track rod arm fouling diff on full lock (2.1.4 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect kick up to right hand side (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect kick up to right hand side (4.1.2 (c)) | 1 |
| Offside Front Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Nearside Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Offside Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Offside Rear Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Nearside Front Inner Electrical wiring insecure and in contact with sharp edges front wheel arch (4.11 (a) (ii)) | 1 |
| Nearside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt forward arm (2.1.3 (g) (ii)) | 1 |
| Offside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt forward arm (2.1.3 (g) (ii)) | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings next to os catalytic converter |6.1.B.2| | 1 |
| Stop lamp remains on when the brakes are released | 1 |
| Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt drop arm |2.2.C.1c| | 1 |
| Hazard warning lamps inoperative all (4.4.1 (e)) | 1 |
| Nearside Rear Electrical wiring likely to touch hot or rotating parts (4.11 (a) (iii)) | 1 |
| Central Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Offside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Nearside Rear Passengers seat insecure 3rd row (6.2.6 (a) (ii)) | 1 |
| Offside Rear Passengers seat insecure 3rd row (6.2.6 (a) (ii)) | 1 |
| Nearside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is severely distorted |3.6.C.3| | 1 |
| Nearside Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Fuel tank leaking middle tank wet with petrol |6.1.3 |b| |i|| | 1 |
| Nearside Rear Suspension rod pin or bush excessively worn radius arm bush front |5.3.4 |a| |i|| | 1 |
| Offside Rear Suspension rod pin or bush excessively worn radius arm bush front |5.3.4 |a| |i|| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Front Service brake juddering severely |3.7.C.2| | 1 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 1 |
| Dipswitch operation does not deflect all main beam headlamps to make them dipped beams (4.1.3 (b)) | 1 |
| Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Offside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced at tow bar mount (6.1.1 (c) (i)) | 1 |
| Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded near steering damper (2.1.2 (e) (i)) | 1 |
| Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.1.6 (i) (i)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Power steering component leaking Steering box (2.1.5 (a)) | 1 |
| Nearside Front Floor excessively deteriorated Battery box (6.2.4 (a) (i)) | 1 |
| Offside Front Floor excessively deteriorated See yellow marker (6.2.4 (a) (i)) | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced See yellow marker (6.1.1 (c) (i)) | 1 |
| Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced See yellow marker (6.1.1 (c) (i)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Cab steps so insecure it is likely to cause injury mounting corroded (6.2.8 (a) (ii)) | 1 |
| Nearside Front Direction indicator likely to become detached (4.4.1 (c) (ii)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Rear Oil leaking excessively from transmission hub seal (8.4.1 (a) (i)) | 1 |
| Steering box leaking to the extent that oil is dripping (2.1.1 (e) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Battery insecure and likely to fall from carrier vehicle floor/ battery tray excessively corroded (4.13 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
| Offside Rear brake disc excessively scored |3.5.1h| | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Central Rear Suspension arm pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Front Suspension component pin or bush excessively worn pan arm (5.3.4 (a) (i)) | 1 |
| Intermediate drop arm damaged and unserviceable |2.2.C.1d| | 1 |
| Offside Front Steering component is not secure to the vehicle structure arm loose |2.2.B.1a| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust has a major leak of exhaust gases exhaust manifold missing two studs (6.1.2 (a)) | 1 |
| Emissions oxygen sensor missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Offside Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Central Sub-frame ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Seat belt stitching badly frayed |5.2.2b| | 1 |
| Offside Rear fog lamp obscured more than 50% |1.3.2c| | 1 |
| Offside Exhaust has a major leak of exhaust gases downpipe |7.1.2| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Offside Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear reflector excessively deteriorated so that its function is impaired |1.5.1c| | 1 |
| Offside Rear Position lamp not working WHEN BRAKES ARE OPERATED. |4.2.1 |a|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen KICK UP ON OFFSIDE | LHD HEADLIGHT FITTED| |4.1.2 |a|| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Emissions not tested Tick over too high |7.3.A.1| | 1 |
| Nearside Track rod end ball joint has excessive play Under load |2.2.B.1f| | 1 |
| Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Stop lamp|s| not working High Level. |4.3.1 |a| |ii|| | 1 |
| Steering linkage ball joint has excessive play from steering box (2.1.3 (b) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
| Nearside Rear Outer Brake pipe inadequately clipped across rear axle case ,clip missing |3.6.B.1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Fuel cap/sealing device sealing washer missing |7.2.4c| | 1 |
| Nearside Front coil spring broken |2.4.C.1a| | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. Does not properly secure in the fore position (6.2.5 (b) (i)) | 1 |
| Headlamp not working on main beam Both |1.7.5a| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Exhaust catalytic converter missing where one was fitted as standard Both sides |7.1.3| | 1 |
| Nearside Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Emissions not tested due to cats not being fitted (8.2.1.2 (d)) | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outrigger / chassis plate behind wheel (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outrigger behind wheel (5.3.6 (a) (i)) | 1 |
| Nearside Rear Towbar excessively corroded within 30cm of towbar mounting chassis rail / rear cross member (6.1.6 (i) (i)) | 1 |
| Offside Rear Towbar excessively corroded within 30cm of towbar mounting chassis rail / rear cross member (6.1.6 (i) (i)) | 1 |
| Centre Front Steering damper damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Front Electrical wiring insecure and in contact with sharp edges (4.11 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases rear exhaust pipe missing |7.1.2| | 1 |
| Rear Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt A frame |2.4.G.2| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Ball joint has excessive play Steering box arm |2.2.B.1f| | 1 |
| Electrical wiring inadequately supported On steering |1.9.2a| | 1 |
| Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Shock absorber has an excessively worn bush Both rear |2.7.4| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Nearside Rear Rear reflector missing |1.5.1a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Steering damper damaged and unserviceable |2.2.C.1d| | 1 |
| Nearside Inner Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Tie bar/rod rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Tie bar/rod rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust has a major leak of exhaust gases also insecure |7.1.2| | 1 |
| Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Inner Upper Stop lamp not working |1.2.1b| | 1 |
| Offside Front Lower Brake pipe likely to become detached or damaged touching lower spring seat on full lock (1.1.11 (d) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Brake fluid contaminated (1.8 (a)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| brake disc excessively pitted |3.5.1h| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Shock absorbers likely to become detached (5.3.2 (a) (ii)) | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.3 |a|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Offside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt drag link at steering box |2.2.C.1c| | 1 |
| Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Inner Electrical wiring insecure and in contact with sharp edges |4.11 |a| |ii|| | 1 |
| Offside Front Outer Brake pipe excessively damaged fouling axle on lock |1.1.11 |c|| | 1 |
| Central Rear Stop lamp not working high level brake light |1.2.1b| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Offside Front brake disc contaminated by brake fluid |3.5.1h| | 1 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Rear Exhaust silencer likely to become detached |8.1.1 |b| |ii|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Front Lower Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Offside Front Lower Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Offside Rear Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Dipswitch does not operate immediately when selected on main beam |4.1.3 |b|| | 1 |
| Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Offside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Offside Rear Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Nearside Rear Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
| Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Offside Front Outer Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Steering box has excessive free play detected at the steering wheel (steering box fitted) (2.3 (a) (i)) | 1 |
| Offside Rear Trailer electrical socket |13 pin| not operating the trailer lamps as intended indicator |1.9.4| | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure (5.3.3 (a) (i)) | 1 |
| Offside Front coil spring fractured |2.4.C.1a| | 1 |
| Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
| Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength "A"frame cross member roll frame mounting (5.3.6 (a) (i)) | 1 |
| Central Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt main axle ball joint (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn chassis bush 3 bolt (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn chassis bush 3 bolt (5.3.4 (a) (i)) | 1 |
| Front Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded seat belt chassis outriggers support bars |5.2.6| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded chassis outrigger support bar |5.2.6| | 1 |
| Power steering component|s| leaking steering box leaking |2.3.3b| | 1 |
| Fuel system component leaking excessively or a risk of fire Filler neck |6.1.3 |b| |ii|| | 1 |
| Nearside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Rear Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Nearside Rear Lower Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Track rod end ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
| Nearside Rear Suspension rod pin or bush excessively worn tie bar front rear bushes |5.3.4 |a| |i|| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Offside Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
| Nearside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Fuel pipe leaking |7.2.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded at a/bar mounting |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Rear Shock absorber has an excessively worn bush both top bushes n/s & o/side |2.7.4| | 1 |
| Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting chassis |6.6.6| | 1 |
| Vehicle structure excessively corroded within 30cm of towbar mounting n/side & o/side rear crossing chassis |6.6.6| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Power steering pump leaking from a failed seal |2.3.3b| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Front Rear fog lamp switch inoperative |4.5.3 |a| |ii|| | 1 |
| Rear Rear fog lamp likely to become detached |4.5.1 |c| |ii|| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Upper Stop lamp not working |1.2.1b| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded In front of rear wheel. |5.2.6| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Central Rear Braking system leaking |3.6.A.1| | 1 |
| Towbar retaining device missing x2 bolts missing. |6.6.3a| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Ball joint dust cover insecure so that it no longer prevents the ingress of dirt drop arm |2.2.C.1c| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear Vehicle structure excessively corroded within 30cm of towbar mounting cross member both sides |6.6.6| | 1 |
| Offside Drag link end ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Upper Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Central Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Front Outer Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance lens broken |1.4.A.2e| | 1 |
| Nearside Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Rear Trailer electrical socket insecure |1.9.3a| | 1 |
| Front Upper Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Fuel tank insecure |7.2.1| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength on chassis in wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis rail (6.1.1 (c) (i)) | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Central Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp |4.2.3 |c|| | 1 |
| Offside Stop lamp|s| adversely affected by the operation of another lamp |4.3.3 |b|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail (5.3.6 (a) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired body mounting (6.2.2 (d) (ii)) | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Steering linkage ball joint has excessive play on steering arm |2.1.3 |b| |i|| | 1 |
| Nearside Drag link end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength out rigger |5.3.6 |a| |i|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Offside Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Stop lamp(s) not working high level. (4.3.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |