| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 16 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Hazard warning switch faulty |1.4.B.1d| | 3 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Service brake: efficiency below requirements |3.7.C.1a| | 3 |
| Fuel system component leaking |7.2.3| | 2 |
| Front brake application uneven | 2 |
| Registration plate lamp issues | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting chassis |6.6.6| | 2 |
| Rear brake binding | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
| Brake pedal spongy |3.3.B.1b| | 2 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 2 |
| Horn not working (7.7 (a)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front All position lamps not working |4.2.1 |a|| | 1 |
| Nearside Front Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear All position lamps not working |4.2.1 |a|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Steering wheel spokes fractured |2.2.1 |c| |i|| | 1 |
| Rear Parking |secondary brake| on a single line braking system has no recorded effort at a wheel |1.3.1 |a| |ii|| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside brake disc contaminated by oil |3.5.1h| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Offside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Rear Service brake lagging in operation |1.2.1 |d|| | 1 |
| Offside Front Brake pipe connection leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |1.1.6 |d|| | 1 |
| Windscreen washer not working | 1 |
| Nearside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Offside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Tie bar/rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Brake pedal feels spongy with the vacuum fully depleted |3.3.C.2| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Front Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 1 |
| Offside Front Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Rear Anti-roll bar fractured |2.4.G.1| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Brake pipe excessively damaged |3.6.B.2c| | 1 |
| Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting chassis |6.6.6| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Rear coil spring broken |2.4.C.1a| | 1 |
| Offside Front Steering locking device missing |2.2.C.1g| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Nearside Rear Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Fuel hose leaking |7.2.3| | 1 |
| Nearside Front Torque/reaction arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Fuel pipe leaking |7.2.3| | 1 |
| Registration plate issues | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Nearside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Nearside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Nearside Rear reflector missing |4.8.2 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Suspension rod pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Dipswitch does not operate immediately when selected on dipped beam |4.1.3 |b|| | 1 |
| Central Front Steering arm deformed to the extent that steering is affected |2.1.3 |c| |ii|| | 1 |
| Nearside Front Steering locking device ineffective on power steering shaft |2.1.3 |d|| | 1 |
| Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Front Exhaust has a major leak of exhaust gases loose at down pipe |7.1.2| | 1 |
| Offside Rear Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Rear Brake hose bulging under pressure on diff |3.6.B.3| | 1 |
| Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |