Most common failures | No# failures |
---|
Headlamp aim out of alignment | 17 |
Registration plate lamp issues | 7 |
Brake hose excessively deteriorated | 6 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Brakes imbalanced across an axle | 4 |
Rear brake binding | 4 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 3 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 3 |
Battery insecure |1.9.1| | 3 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Stop lamp not working |1.2.1b| | 3 |
Parking brake lever has no reserve travel |3.1.6b| | 3 |
Brake pipe excessively corroded | 3 |
Service brake: efficiency below requirements |3.7.C.1a| | 3 |
Rear Mechanical brake component has restricted free movement | 3 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Windscreen wiper blade missing |8.2.2| | 2 |
Direction indicators not working |1.4.A.2c| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Horn not working |1.6.2a| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Parking brake: efficiency below requirements |3.7.B.7| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Steering system excessively tight |2.2.D.1| | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
Steering box has a significant oil leak |2.2.D.2e| | 2 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
Offside front brake recording little or no effort |3.7.B.5a| | 2 |
Offside Front Headlamp not working on main beam |1.7.5a| | 2 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 2 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 2 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Brake pedal spongy |3.3.B.1b| | 2 |
Steering wheel retaining device insecure |2.1.6| | 2 |
Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Offside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Registration plate issues | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Bonnet cannot be secured in the closed position |8.4.1| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Offside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Front Trailing arm locating pin insecure |2.4.G.3a| | 1 |
Centre Rear Upper Torque/reaction arm has excessive play in a ball joint |2.4.G.2| | 1 |
Rear Upper Torque/reaction arm locating pin locking device missing |2.4.G.3b| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Position lamp switch faulty |1.1.A.1| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Driver`s door pillar insecure |6.2.B.2| | 1 |
Nearside Driver`s door pillar insecure |6.2.B.2| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
Offside Rear Rear reflector missing |1.5.1a| | 1 |
Nearside Side repeater missing |1.4.A.2b| | 1 |
Offside Side repeater missing |1.4.A.2b| | 1 |
Offside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
Steering component is not secure to the vehicle structure Steering damper |2.2.B.1a| | 1 |
Panhard rod attachment bracket/mounting insecure |2.4.G.1| | 1 |
Offside Intermediate drop arm insecure |2.2.B.1a| | 1 |
Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
Offside Front All position lamps not working |1.1.A.3b| | 1 |
Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
Offside Seat belt anchorage prescribed area is fractured |5.2.6| | 1 |
Nearside Front Suspension spring mounting prescribed area is fractured |2.4.A.3| | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Parking brake: efficiency below requirements |3.7.D.4| | 1 |
Parking brake lever, pawl mechanism pivot|s| or their associated mountings locking device insecure |3.1.4b| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Nearside Rear front brake binding |3.7.B.1| | 1 |
Offside Rear front brake binding |3.7.B.1| | 1 |
Nearside Front An item not tested |Manual| | 1 |
Offside Front An item not tested |Manual| | 1 |
Nearside Rear An item not tested |Manual| | 1 |
Offside Rear An item not tested |Manual| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Front passenger seat insecure |6.2.3| | 1 |
Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Brake pipe inadequately supported flexi to drum |3.6.B.1| | 1 |
Offside Front Brake pipe inadequately supported flexi to drum |3.6.B.1| | 1 |
Offside Front Brake pipe leaking to cylinder |3.6.A.1| | 1 |
Ball joint has excessive play steering arm to drop arm |2.2.B.1f| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Central Exhaust system not adequately supported exhaust hanger corroded and broken |7.1.1| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Leaf spring shackle bracket corroded and seriously weakened |2.4.B.6d| | 1 |
Offside Leaf spring shackle bracket corroded and seriously weakened |2.4.B.6d| | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
brake disc contaminated by oil parking brake and pads gearbox |3.5.1h| | 1 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.1 |c| |ii|| | 1 |
Nearside Rear Leaf spring anchor bracket corroded and seriously weakened |5.3.1 |b| |i|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Nearside Rear Hydraulic brake cylinder leaking and braking performance affected |1.1.16 |b| |ii|| | 1 |
Offside Rear Hydraulic brake cylinder leaking and braking performance affected |1.1.16 |b| |ii|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Rear Drag link end loose |2.2.B.1d| | 1 |
Rear reflector missing |1.5.1a| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Steering box insecure |2.2.B.1a| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
Offside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Obligatory mirror missing |8.1.1| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Windscreen wiper does not clear the windscreen effectively | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Towbar component insecure |6.6.1| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings by door pillar |6.1.B.2| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings by door pillar |6.1.B.2| | 1 |
Offside Front Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings chassis end of out rigger for body mount |6.1.B.2| | 1 |
Rear Brake pipe kinked over axle crushed |3.6.B.2b| | 1 |
Nearside Front Track rod end ball joint has excessive play inner of the 2 marked in yellow |2.2.B.1f| | 1 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded chassis |2.4.A.3| | 1 |
Nearside Front Suspension spring mounting prescribed area is inadequately repaired chassis |2.4.A.3| | 1 |
Offside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
Offside Rear Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Rear Position lamp switch does not operate in accordance with the requirements go off when head lights turned on (4.2.2 (a)) | 1 |
Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |