Most common failures | No# failures |
---|
Headlamp aim out of alignment | 208 |
Brakes imbalanced across an axle | 153 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 137 |
Windscreen wiper does not clear the windscreen effectively | 118 |
Registration plate lamp issues | 113 |
Rear brake binding | 81 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 80 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 78 |
Offside Stop lamp not working |1.2.1b| | 74 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 73 |
Parking brake: efficiency below requirements |3.7.C.1b| | 71 |
Nearside Stop lamp not working |1.2.1b| | 68 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 64 |
Horn not working |1.6.2a| | 60 |
Service brake: efficiency below requirements |3.7.C.1a| | 59 |
Parking brake: efficiency below requirements |3.7.B.7| | 57 |
Brake pipe excessively corroded | 51 |
Brake hose excessively deteriorated | 49 |
Registration plate issues | 49 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 46 |
Service brake: efficiency below requirements |3.7.B.7| | 42 |
Offside Front position lamp|s| not working |1.1.A.3b| | 41 |
Offside Headlamp not working on dipped beam |1.7.5a| | 35 |
Front brake application uneven | 35 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 33 |
Exhaust has a major leak of exhaust gases |7.1.2| | 32 |
Parking brake lever has no reserve travel |3.1.6b| | 31 |
Rear brake application uneven | 31 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 30 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 29 |
Nearside front brake binding |3.7.B.1| | 28 |
Rear Exhaust system not adequately supported |7.1.1| | 27 |
Battery insecure |1.9.1| | 27 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 26 |
Nearside Headlamp not working on main beam |1.7.5a| | 25 |
Offside Headlamp not working on main beam |1.7.5a| | 25 |
Brake pedal spongy |3.3.B.1b| | 25 |
Nearside Front Direction indicator not working |1.4.A.2c| | 24 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 24 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 23 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 22 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 22 |
Direction indicators not working |1.4.A.2c| | 22 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 22 |
Offside Front Direction indicator not working |1.4.A.2c| | 21 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 21 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 21 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 21 |
Offside Rear Stop lamp not working |1.2.1b| | 21 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 20 |
Offside front brake binding |3.7.B.1| | 20 |
Nearside Rear Stop lamp not working |1.2.1b| | 20 |
Fuel cap/sealing device sealing washer missing |7.2.4c| | 19 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 18 |
Brake performance not tested |3.7.A.1| | 18 |
Exhaust system not adequately supported |7.1.1| | 18 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 17 |
Offside Rear reflector missing |1.5.1a| | 17 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 16 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 16 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 16 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 16 |
Rear parking brake recording little or no effort | 15 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 15 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 15 |
Nearside front brake recording little or no effort |3.7.B.5a| | 14 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 14 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 14 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 14 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 14 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 13 |
Offside Rear Braking system leaking |3.6.A.1| | 12 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 12 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 12 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 12 |
Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 12 |
Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 12 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 12 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 12 |
Offside Rear Direction indicator not working |1.4.A.2c| | 12 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 11 |
Intermediate drop arm insecure |2.2.B.1a| | 11 |
Offside rear brake recording little or no effort |3.7.B.5a| | 11 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 11 |
Steering system excessively tight |2.2.D.1| | 11 |
Nearside Rear reflector missing |1.5.1a| | 11 |
Mechanical brake component has restricted free movement | 11 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 11 |
Rear Mechanical brake component has restricted free movement | 11 |
Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 10 |
Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 10 |
Nearside Rear brake drum contaminated by oil |3.5.1h| | 10 |
Offside Rear brake drum contaminated by oil |3.5.1h| | 10 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 10 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 10 |
Brake pipe inadequately clipped |3.6.B.1| | 10 |
Centre Exhaust system not adequately supported |7.1.1| | 10 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 10 |
Stop lamp not working |1.2.1b| | 10 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 10 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 9 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 9 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 9 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 9 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 9 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 9 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 9 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 9 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 9 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 8 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 8 |
Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 8 |
Offside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 8 |
Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 8 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 8 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 8 |
Offside Front Direction indicators not working |1.4.A.2c| | 8 |
Windscreen washer not working | 8 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 8 |
Nearside Front Direction indicators not working |1.4.A.2c| | 8 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 8 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 8 |
Rear Stop lamp not working |1.2.1b| | 7 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 7 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 7 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 7 |
Offside front brake recording little or no effort |3.7.B.5a| | 7 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 7 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 7 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 7 |
Offside Front Axle swivel joint has excessive play |2.5.A.3b| | 7 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 7 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 7 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 7 |
Fuel tank leaking |7.2.3| | 7 |
Indicator tell tale inoperative |1.4.A.2a| | 7 |
Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 6 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 6 |
Steering box insecure |2.2.B.1a| | 6 |
Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 6 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 6 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |
Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 6 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 6 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 6 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 6 |
Nearside Front front brake recording little or no effort |3.7.B.5a| | 6 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 6 |
Offside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 6 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 6 |
Hazard warning switch faulty |1.4.B.1d| | 6 |
Nearside Rear wheel cylinder leaking |3.6.A.1| | 6 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 6 |
Offside Front front brake binding |3.7.B.1| | 6 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 6 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 6 |
Emissions not tested |7.0| | 6 |
Nearside Windscreen wiper blade missing |8.2.2| | 5 |
Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Nearside Front brake drum contaminated by oil |3.5.1h| | 5 |
Offside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 5 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 5 |
Windscreen wiper blade insecure | 5 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 5 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 5 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 5 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 5 |
Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 5 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 5 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 5 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 5 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Offside Rear Leaf spring fractured |2.4.B.1a| | 5 |
Windscreen has damage | 5 |
Nearside Rear Direction indicators not working |1.4.A.2c| | 5 |
Nearside Headlamp insecure |1.7.3| | 5 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 5 |
Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 5 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 5 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 5 |
Offside Front Brake pipe inadequately supported |3.6.B.1| | 5 |
Nearside Rear Leaf spring splayed and action impaired |2.4.B.1c| | 5 |
Offside Front Leaf spring to axle securing nut insecure |2.4.B.7b| | 5 |
Steering column top bearing excessively worn |2.1.2c| | 5 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 5 |
Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 5 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 5 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 5 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 5 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 5 |
Offside Front Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 4 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 4 |
Offside Front brake drum contaminated by oil |3.5.1h| | 4 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
Rear fog lamp not working |1.3.2b| | 4 |
Nearside Front Braking system leaking |3.6.A.1| | 4 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 4 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 4 |
Offside Rear Direction indicators not working |1.4.A.2c| | 4 |
Offside Rear wheel bearing has excessive play |2.6.2| | 4 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 4 |
Nearside Front front brake binding |3.7.B.1| | 4 |
Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 4 |
Nearside Front Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 4 |
Offside Rear brake drum contaminated by brake fluid |3.5.1h| | 4 |
Nearside Rear Braking system leaking |3.6.A.1| | 4 |
Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 4 |
Offside Headlamp insecure |1.7.3| | 4 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 4 |
Nearside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 4 |
Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 4 |
Nearside Axle swivel joint has excessive play |2.5.A.3b| | 4 |
Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 4 |
Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 4 |
Offside Front Leaf spring fractured |2.4.B.1a| | 4 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Nearside Front brake drum contaminated by brake fluid |3.5.1h| | 4 |
Main beam `tell-tale` not working |1.7.4c| | 4 |
Bonnet cannot be secured in the closed position |8.4.1| | 4 |
Offside Rear Leaf spring damaged and permanently distorted |2.4.B.1a| | 4 |
Nearside Rear Leaf spring deteriorated and seriously weakened |2.4.B.1a| | 4 |
Offside Front Statutory seat belt missing |5.1.1| | 4 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 4 |
Rear Braking system leaking |3.6.A.1| | 4 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 4 |
Central Exhaust system not adequately supported |7.1.1| | 4 |
Indicator switch faulty |1.4.A.1| | 4 |
Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 4 |
Fuel system component leaking |7.2.3| | 4 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
Speedometer cannot be illuminated. |6.7.3| | 4 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Centre Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 4 |
Driver`s seat insecure |6.2.A.1| | 4 |
Offside Rear Leaf spring splayed and action impaired |2.4.B.1c| | 4 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 4 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |