| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 14 |
| Brakes imbalanced across an axle | 11 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Horn not working |1.6.2a| | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Rear brake binding | 5 |
| Front brake application uneven | 4 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Registration plate lamp issues | 4 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Registration plate issues | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Brake pipe excessively corroded | 3 |
| Brake performance not tested |3.7.A.1| | 3 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
| Service brake: efficiency below requirements |3.7.C.1a| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Battery insecure |1.9.1| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Offside Front Direction indicator not working |1.4.A.2c| | 3 |
| Mechanical brake component has restricted free movement | 2 |
| Steering system excessively tight |2.2.D.1| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front Upper Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 2 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Headlamp not working on dipped beam |1.7.5a| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
| Offside Rear Shock absorber detached |2.7.2b| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Front Upper Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Offside Front Statutory seat belt missing |5.1.1| | 1 |
| Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Driver`s door pillar insecure |6.2.3 |c| |ii|| | 1 |
| All direction indicators not working |4.4.1 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases downpipe flange |6.1.2 |a|| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded chassis @ steering box |2.1.2 |e| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear spring hanger |5.3.6 |a| |i|| | 1 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner chassis @ cross member |5.3.6 |a| |i|| | 1 |
| Oil leaking excessively from engine oil filter housing |8.4.1 |a| |i|| | 1 |
| Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Nearside Exhaust system not adequately supported |7.1.1| | 1 |
| Fuel tank insecure |7.2.1| | 1 |
| Offside Front Bonded suspension unit attachment corroded and seriously weakened |2.4.F.1c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Wheel bearing so rough it is likely to overheat or break up |5.1.3 |b| |ii|| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
| Speedometer clearly inoperative |6.7.2| | 1 |
| Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Service brake grabbing severely |3.7.C.2| | 1 |
| Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) | 1 |
| Brake performance not tested nsf siezed (1.2.1 (g)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Offside Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Body insecure and dangerous to other road users 2nd outrigger mount corroded/missing |6.1.B.1b| | 1 |
| Offside Body insecure and dangerous to other road users 2nd outrigger mount adrift |6.1.B.1b| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Rear Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Offside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Brake pedal has no servo assistance |3.3.B.2| | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Fuel pipe leaking both tanks |7.2.3| | 1 |
| Headlamp not working on main beam |1.7.5a| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Front Windscreen wiper control missing |8.2.1a| | 1 |
| Front Windscreen washer control missing |8.2.1a| | 1 |
| Centre Front Statutory seat belt missing |5.1.1| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Leaf spring cracked |2.4.B.1a| | 1 |
| Wheel insecure |4.2.A.1c| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Outer Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Outer Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Rear Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Rear Drive shaft uj which forms part of the suspension has a loose flange bolt |2.4.G.4c| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Leaf spring cracked |2.4.B.1a| | 1 |
| Offside Rear wheel cylinder has restricted free movement |3.5.1k| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Front Upper Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
| Steering locking device missing |2.2.C.1g| | 1 |
| front brake binding |3.7.B.1| | 1 |
| Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Lower Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Front Axle swivel joint has excessive movement between a swivel joint and its housing |2.5.A.1b| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Steering box has excessive movement between sector shaft and the drop arm (2.1.3 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Seat belt missing (7.1.2 (a)) | 1 |
| Nearside Front Seat belt missing (7.1.2 (a)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength to centre chassis (5.3.6 (a) (i)) | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength centre to rear chassis (5.3.6 (a) (i)) | 1 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength centre to rear chassis (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| Steering box leaking to the extent that oil is dripping (2.1.1 (e) (ii)) | 1 |
| Steering system excessively rough (2.1.1 (a)) | 1 |
| Service brake is causing the vehicle to swerve to the offside (1.2.1 (b) (i)) | 1 |
| Offside Front Service brake grabbing severely (1.2.1 (c)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
| brake drum insecure |3.5.1i| | 1 |
| Windscreen has damage | 1 |
| Brake linkage excessively worn and seriously weakened |3.5.1e| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Windscreen washer not working | 1 |
| Front Windscreen wiper not working |3.4 |a|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Front Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Offside Front Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Offside Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Offside Rear Shock absorber insecure |2.7.2b| | 1 |
| front brake binding both |3.7.B.1| | 1 |
| Headlamp not working on dipped beam both |1.7.5a| | 1 |
| Headlamp not working on main beam both |1.7.5a| | 1 |
| front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Brake pedal has insufficient reserve movement brakes require pumping before they work |3.3.A.5| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Offside Front Front suspension locking device ineffective |2.5.A.4| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear brake application uneven | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |