Most common failures | No# failures |
---|
Headlamp aim out of alignment | 12 |
Horn not working |1.6.2a| | 11 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 11 |
Brakes imbalanced across an axle | 8 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Registration plate lamp issues | 7 |
Nearside Stop lamp not working |1.2.1b| | 7 |
Offside Stop lamp not working |1.2.1b| | 6 |
Service brake: efficiency below requirements |3.7.C.1a| | 6 |
Battery insecure |1.9.1| | 6 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Registration plate issues | 6 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Brake pipe excessively corroded | 5 |
Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
Rear brake application uneven | 4 |
Brake performance not tested |3.7.A.1| | 4 |
Indicator tell tale inoperative |1.4.A.2a| | 4 |
Parking brake: efficiency below requirements |3.7.B.7| | 3 |
Rear brake binding | 3 |
Rear Stop lamp not working |1.2.1b| | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Offside Front front brake binding |3.7.B.1| | 3 |
Brake hose excessively deteriorated | 3 |
Nearside Rear reflector missing |1.5.1a| | 3 |
Offside Rear reflector missing |1.5.1a| | 3 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Offside Rear Stop lamp not working |1.2.1b| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 2 |
Steering box insecure |2.2.B.1a| | 2 |
Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 2 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
Direction indicators not working |1.4.A.2c| | 2 |
Electrical wiring inadequately supported |1.9.2a| | 2 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 2 |
Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 2 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
Nearside Front Axle swivel joint has excessive play |2.5.A.3b| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
Offside Front Upper Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Windscreen washer control missing |8.2.1a| | 2 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Rear Shock absorber insecure |2.7.2b| | 1 |
Offside Rear Shock absorber insecure |2.7.2b| | 1 |
Parking brake lever, pawl mechanism pivot|s| locking device missing |3.1.4b| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Towbar component insecure |6.6.1| | 1 |
Offside Front Leaf spring anchor bracket loose |2.4.B.6a| | 1 |
Offside Rear Road wheel badly damaged |4.2.A.1a| | 1 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Steering box insecure steering box to mount plate and mount plate to chassis |2.2.B.1a| | 1 |
Offside Front Steering pivot point has excessive play hub - tractor joint - excessive play in pins/bushes |2.2.B.1g| | 1 |
Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Rear Brake back plate|s| securing device excessively deteriorated |3.5.1j| | 1 |
Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Exhaust has a major leak of exhaust gases centre section |6.1.2 |a|| | 1 |
Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
Offside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Front brake drum contaminated by oil |3.5.1h| | 1 |
Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
Bonnet retaining device excessively deteriorated |8.4.2| | 1 |
Rear All position lamps not working |1.1.A.3b| | 1 |
Front All position lamps not working |1.1.A.3b| | 1 |
Front Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
Centre Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Outer Vehicle structure is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Indicator tell tale missing |1.4.A.2a| | 1 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Exhaust emits dense blue smoke at idle |7.3.A.2b| | 1 |
Offside Front Upper Brake master cylinder/servo mounting prescribed area is excessively corroded bulkhead |3.6.C.3| | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Steering pivot point has excessive play |2.2.B.1g| | 1 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Rear position lamp|s| not working |1.1.A.3b| | 1 |
Windscreen wiper control missing |8.2.1a| | 1 |
Exhaust engine idle speed too high |7.3.A.2a| | 1 |
Position lamp switch insecure |1.1.A.1| | 1 |
brake drum contaminated by oil park brake |3.5.1h| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
Parking brake lever, pawl mechanism pivot|s| retaining device insecure |3.1.4b| | 1 |
Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Steering wheel retaining device insecure |2.1.6| | 1 |
Steering wheel locking device insecure |2.1.6| | 1 |
Nearside Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Steering lock stop incorrectly adjusted |2.2.D.2c| | 1 |
Nearside Steering system fouling drag link |2.2.D.2a| | 1 |
Towbar locking device missing |6.6.3b| | 1 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Main beam `tell-tale` not working |1.7.4c| | 1 |
Steering component mounting prescribed area is excessively corroded bulkhead/door piller |2.2.C.1h| | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded bulkhead |3.6.C.3| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded chassis rail |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded chassis rail |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded chassis/outrigger |2.4.A.3| | 1 |
Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded chassis rail |2.4.A.3| | 1 |
Rear Electrical wiring inadequately supported |1.9.2a| | 1 |
Rear Electrical wiring deteriorated and bare wires exposed |1.9.2c| | 1 |
Offside Electrical wiring inadequately supported centre |1.9.2a| | 1 |
Stop lamp remains on when the brakes are released | 1 |
Offside Front Brake pipe leaking |3.6.A.1| | 1 |
Offside Front Electrical wiring insecure |1.9.2a| | 1 |
Offside Rear Electrical wiring insecure |1.9.2a| | 1 |
Semaphore indicator tell tale not working correctly |1.4.C.2| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings in 2 places as marked |just forward of the rear wheel| |6.1.B.2| | 1 |
Brake pedal has no servo assistance |3.3.B.2| | 1 |
Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` wipers not parking automatically |8.3.1b| | 1 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Steering component mounting prescribed area is excessively corroded cross member by steering idler |2.2.C.1h| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded front mounting |2.4.A.3| | 1 |
Front brake application uneven | 1 |
Offside Front Driver`s door pillar insecure |6.2.B.2| | 1 |
Nearside Front Driver`s door pillar insecure |6.2.B.2| | 1 |
Nearside Front Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
Offside Front Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
Nearside Front Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front Windscreen wiper blade missing |8.2.2| | 1 |
Offside Front Windscreen wiper blade missing |8.2.2| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Emissions not tested |7.0| | 1 |
Headlamp aim not tested |1.8.A.1c| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Front Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Offside Front Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
Nearside Front Lower Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
Steering system fouling |2.2.D.2a| | 1 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Exhaust has a major leak of exhaust gases centre silencer |6.1.2 |a|| | 1 |
Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |8.1.1 |a|| | 1 |
Nearside Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Brake has no servo assistance |3.3.B.2| | 1 |
Offside Front Lower Steering locking device insecure |2.2.C.1g| | 1 |
Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Front Windscreen washer control is inaccessible to the driver |8.2.1a| | 1 |
All position lamps not working and h/lamps |1.1.A.3b| | 1 |
Headlamp not working on dipped beam |1.7.5a| | 1 |
Headlamp not working on main beam |1.7.5a| | 1 |
Steering locking device insecure |2.2.C.1g| | 1 |
Nearside Direction indicator not working |1.4.A.2c| | 1 |
Front passenger door does not latch securely closed |6.2.B.1a| | 1 |
Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Centre Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Indicator switch insecure |1.4.A.1| | 1 |
Statutory seat belt missing |5.1.1| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Rear Braking system leaking |3.6.A.1| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Exhaust system not adequately supported |7.1.1| | 1 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Stop lamp not working incorrect fitting |1.2.1b| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front front brake binding |3.7.B.1| | 1 |
Nearside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Offside Front Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Brake hose connection leaking on an air braking system |1.1.12 |c| |i|| | 1 |
Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting |6.2.2 |d| |i|| | 1 |
Nearside Front Leaf spring has excessive wear in a shackle pin and/or bush rear shackle bush |2.4.B.2| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
Parking brake: efficiency below requirements |3.7.D.4| | 1 |
Front Fuel pipe leaking |7.2.3| | 1 |
Offside Track rod end loose |2.2.B.1d| | 1 |
Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |