Most common failures | No# failures |
---|
Headlamp aim out of alignment | 33 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 26 |
Registration plate lamp issues | 19 |
Brake pipe excessively corroded | 11 |
Registration plate issues | 10 |
Nearside Stop lamp not working |1.2.1b| | 10 |
Horn not working |1.6.2a| | 10 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 9 |
Offside Stop lamp not working |1.2.1b| | 8 |
Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
Brakes imbalanced across an axle | 7 |
Windscreen wiper does not clear the windscreen effectively | 7 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Parking brake: efficiency below requirements |3.7.B.7| | 5 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Parking brake: efficiency below requirements |3.7.C.1b| | 5 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Service brake: efficiency below requirements |3.7.C.1a| | 4 |
Rear brake binding | 4 |
Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
Windscreen washer not working | 4 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 3 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 2 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 2 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Shock absorber has an excessively worn bush |2.7.4| | 2 |
Fuel cap/sealing device sealing washer torn |7.2.4c| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Rear Leaf spring anchor bracket loose |2.4.B.6a| | 2 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Rear brake drum contaminated by brake fluid |3.5.1h| | 2 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Rear Leaf spring shackle bracket loose |2.4.B.6a| | 2 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
Front brake excessively fluctuating | 2 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Stop lamp(s) remains on when the brakes are released (4.3.2 (a) (iii)) | 1 |
Front Prop shaft joint excessively worn both front prop shaft u-jays worn (6.1.7 (c) (i)) | 1 |
Nearside Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
Nearside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Offside Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
Offside Rear Brake pipe excessively chafed |3.6.B.2c| | 1 |
Power steering component|s| leaking steering box |2.3.3b| | 1 |
Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Brake hydraulic reservoir leaking hydraulic fluid |3.6.A.1| | 1 |
Rear brake application uneven | 1 |
Offside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
Offside Front Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
An item not tested |Manual| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Front brake application uneven | 1 |
Front front brakes release unevenly |3.7.B.4| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Suspension component mounting prescribed area excessively corroded significantly reducing structural strength nearside rear chassis at rear spring mount (5.3.6 (a) (i)) | 1 |
Suspension component mounting prescribed area excessively corroded significantly reducing structural strength offside rear chassis at rear spring mount (5.3.6 (a) (i)) | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Front Statutory seat belt missing |5.1.1| | 1 |
Offside Front Statutory seat belt missing |5.1.1| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Brake hose has insufficient room to move | 1 |
Windscreen wiper not working |3.4 |a|| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Front position lamp|s| adversely affected by the operation of another lamp flashing when indicator operated |1.1.A.3f| | 1 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded rear most leaf spring mount |chassis| |2.4.A.3| | 1 |
Nearside Rear Inner Suspension spring mounting prescribed area is excessively corroded rear most leaf spring mount |cross member| |2.4.A.3| | 1 |
Nearside Rear Outer Suspension spring mounting prescribed area is excessively corroded rear most leaf spring mount |cross member| |2.4.A.3| | 1 |
Offside Rear Inner Suspension spring mounting prescribed area is excessively corroded rear most leaf spring mount |cross member| |2.4.A.3| | 1 |
Offside Rear Outer Suspension spring mounting prescribed area is excessively corroded rear most leaf spring mount |cross member| |2.4.A.3| | 1 |
Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt at steering box |2.2.C.1c| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Nearside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Centre Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Leaf spring anchor bracket loose |2.4.B.6a| | 1 |
Nearside Rear reflector insecure |1.5.1a| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Rear Headlamp not working on main beam |1.7.5a| | 1 |
Offside Rear brake drum contaminated by oil |3.5.1h| | 1 |
Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Front brake caliper securing device missing both |3.5.1j| | 1 |
Centre Exhaust system not adequately supported mount broken |7.1.1| | 1 |
Front Lower Anti-roll bar has excessive play in a pin/bush both |2.4.G.2| | 1 |
Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cross chassis member |6.1.B.2| | 1 |
Nearside Rear Leaf spring cracked |2.4.B.1a| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Vehicle structure has damage which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front Anti-roll bar linkage rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Obligatory mirror seriously obscured affecting the rear view |8.1.2a| | 1 |
Nearside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Prop shaft joint so worn it is likely to fail front prop both ujs (6.1.7 (c) (ii)) | 1 |
Brake servo damaged and function impaired |3.6.A.2c| | 1 |
front brake recording little or no effort |3.7.B.5a| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Brake servo leaking |3.6.C.1c| | 1 |
Brake hose excessively deteriorated | 1 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Nearside Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
Steering wheel retaining device insecure |2.1.6| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
Offside Axle swivel joint has excessive play in a swivel pin |2.5.A.3b| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Leaf spring shackle bracket loose |2.4.B.6a| | 1 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Brake servo defective or ineffective (1.1.10 (a) (i)) | 1 |
Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Indicator tell tale inoperative |1.4.A.2a| | 1 |
Nearside Rear reflector not red in colour |1.5.1d| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded cross member |2.4.A.3| | 1 |
Stop lamp not working both |1.2.1b| | 1 |
Mechanical brake component has restricted free movement | 1 |
Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
Offside rear brake excessively fluctuating |3.7.B.3| | 1 |
Steering column top mounting bracket insecure |2.1.2d| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Service brake is causing the vehicle to swerve to the offside |3.7.C.2| | 1 |
Speedometer clearly inoperative |6.7.2| | 1 |
Rear Position lamp adversely affected by the operation of another lamp x2 |4.2.3 |c|| | 1 |
Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Nearside Front Upper Shock absorbers has an excessively worn bush |5.3.2 |c|| | 1 |
Brake performance not tested brake lamps not working and road brake test required |3.7.A.1| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Brake linkage locking device missing park cable clevis pin has split pin missing |3.5.1l| | 1 |
Offside Lower Seat belt anchorage prescribed area is excessively corroded outer panel |5.2.6| | 1 |
Nearside Rear Lower Leaf spring to axle fixing bolt insecure "u" bolts |5.3.1 |a| |i|| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Dipswitch operation does not deflect all main beam headlamps to make them dipped beams |1.7.4b| | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
Offside Rear Leaf spring saddle is moving relative to the spring |2.4.B.7a| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Drag link end loose |2.2.B.1d| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Obligatory mirror insecure |8.1.1| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Braking system leaking |3.6.A.1| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Exhaust engine idle speed too high |7.3.A.2a| | 1 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Brake pedal creeps down under servo assistance and touches the floor |3.3.C.3| | 1 |
Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Nearside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
Offside Front brake drum contaminated by oil |3.5.1h| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |