| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 14 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Horn not working |1.6.2a| | 7 |
| Brakes imbalanced across an axle | 5 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Registration plate lamp issues | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Nearside Headlamp not working on main beam |1.7.5a| | 4 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Front Steering locking device missing |2.2.C.1g| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Front Headlamp not working on main beam |1.7.5a| | 2 |
| Brake hose has insufficient room to move | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Rear Brake pipe excessively damaged |3.6.B.2c| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Rear brake binding | 2 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings sill to floor |6.1.B.2| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Front Lower Front suspension retaining device missing ball joint split pin |2.5.A.4| | 1 |
| Offside Front brake caliper leaking |3.6.A.1| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Braking system leaking caliper |3.6.A.1| | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front brake disc contaminated by grease |3.5.1h| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Rear reflector missing |1.5.1a| | 1 |
| Nearside Front Ball joint has excessive play joint chalked for clarity |2.2.B.1f| | 1 |
| Front Drag link end ball joint has excessive play chalked |2.2.B.1f| | 1 |
| Nearside Front Drag link end ball joint has excessive play chalked |2.2.B.1f| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Service brake: efficiency below requirements (3.7.B.7) | 1 |
| Parking brake: efficiency below requirements (3.7.B.7) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area is inadequately repaired sill (2.4.A.3) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area is inadequately repaired sill (2.4.A.3) | 1 |
| Nearside Subframe mounting prescribed area is inadequately repaired floor to sill (2.4.A.3) | 1 |
| Offside Subframe mounting prescribed area is inadequately repaired floor to sill (2.4.A.3) | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement D bush (2.4.G.2) | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp (1.4.A.2h) | 1 |
| Offside Stop lamp not working (1.2.1b) | 1 |
| Stop lamp not working (1.2.1b) | 1 |
| Windscreen wiper not operating automatically when switched on (8.2.1b) | 1 |
| Headlamp aim beam image kick up to the offside (1.8) | 1 |
| Nearside Front Suspension has inadequate clearance with the bump stop (2.4.A.1a) | 1 |
| Offside Front Suspension has inadequate clearance with the bump stop (2.4.A.1a) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Fuel system component leaking Fuel pump? |7.2.3| | 1 |
| Nearside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Electrical wiring damaged, likely to cause a short |1.9.2b| | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Subframe mounting prescribed area is fractured |2.4.A.3| | 1 |
| Nearside Front brake caliper securing device missing |3.5.1j| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded Shackle Mount |2.4.A.3| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Headlamp aim beam image obviously incorrect both |1.8.A.1b| | 1 |
| Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Dipswitch operation does not extinguish all main beam headlamps leaving at least one pair of dipped beam headlamps |1.7.4b| | 1 |
| Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Offside Track rod end loose |2.2.B.1d| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Rear Shock absorbers insecurely attached 1x nut as missing (5.3.2 (a) (i)) | 1 |
| Offside Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Inner Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Registration plate issues | 1 |
| Fuel tank leaking neck/tank |7.2.3| | 1 |
| Nearside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Nearside Rear Brake linkage locking device missing |3.5.1l| | 1 |
| Front brake application uneven | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a) | 1 |
| Nearside Inner Track rod end ball joint has excessive play (2.2.B.1f) | 1 |
| Offside Inner Track rod end ball joint has excessive play (2.2.B.1f) | 1 |
| Nearside Track rod end ball joint worn to the extent there is a serious risk of detachment Nut missing (2.1.3 (b) (ii)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Front All position lamps not working |1.1.A.3b| | 1 |
| Offside Inner Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Nearside Rear Parking brake lever, pawl mechanism pivot|s| locking device missing |3.1.4b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |